1999 ISUZU VehiCROSS

Isuzu VehiCROSS 1999 - BUZZERS, RELAYS & TIMERS

Isuzu VehiCROSS 1999 BUZZERS, RELAYS & TIMERS

Component	Component Location
Anti-Theft Buzzer	Left rear of engine compartment.
Condenser Fan Relay	In fuse/relay box.
Flasher Unit	Above left kick panel.
Fuel Pump Relay	In fuse/relay box.
Headlight Relay	In fuse/relay box.
Heater & A/C Relay	In fuse/relay box.
Horn Relay	In fuse/relay box.
Passenger Door Lock Control Relay	Behind right kick panel.
PCM Main Relay	In fuse/relay box.
Power Window Relay	Behind left kick panel.
Rear Defogger Relay	Behind left kick panel.
Starter Relay	In fuse/relay box.
Taillight Relay	Behind left kick panel.
Warning Buzzer	Behind left kick panel.
Windshield Wiper Intermittent Relay	Behind right kick panel.

Isuzu VehiCROSS 1999 - CIRCUIT PROTECTION DEVICES

Isuzu VehiCROSS 1999 CIRCUIT PROTECTION DEVICES

Component	Component Location
Dash Fuse Box	Behind left kick panel.
Fuse/Relay Box	On right side of engine compartment. See Fig. 1 .

Isuzu VehiCROSS 1999 - CONTROL UNITS

Isuzu VehiCROSS 1999 CONTROL UNITS

Component	Component Location
A/T Shift Indicator Control Unit	Behind dash, left of steering column.
Anti-Theft & Keyless Entry Control Unit	Behind dash, left of steering column.
Cruise Control Unit	Behind right kick panel.
Electronic Brake Control Module (EBCM)	Right rear of engine compartment.
Flasher Unit	Above left kick panel.
Powertrain Control Module (PCM)	Behind front console.
Sensing & Diagnostic Module	Below center of dash.
Shift Lock Controller	Below front console.
Torque On Demand (TOD) Control Unit	Beneath front passenger's seat.

Isuzu VehiCROSS 1999 - MOTORS

Isuzu VehiCROSS 1999 MOTORS

Component	Component Location
Blower Motor	Below right side of dash.
Condenser Fan	Behind right side of radiator grille.
Cruise Control Actuator	Right rear corner of engine compartment.
Fuel Pump	Top of fuel tank.
Idle Air Control (IAC) Valve	On air intake assembly. See Fig. 1 .
Windshield Washer Motor	On right front of engine compartment, bottom of washer fluid reservoir.
Windshield Wiper Motor	In engine compartment, right side of firewall.

Isuzu VehiCROSS 1999 - SENDING UNITS & SENSORS

Isuzu VehiCROSS 1999 SENDING UNITS & SENSORS

Component	Component Location
ABS Speed Sensors (4)	On inside of respective wheel.
Camshaft Position (CMP) Sensor	On rear of left cylinder head. See Fig. 2 .
Crankshaft Position (CKP) Sensor	On lower right side of engine block. See Fig. 4 .
Electronic Thermostat	Behind glove box.
Engine Coolant Temperature (ECT) Sensor	On right front of engine. See Fig. 3 .
Front Speed Sensor (Transfer)	On top rear of transfer case.
Fuel Vapor Pressure Sensor	On top of fuel tank.
"G" Sensor (ABS)	Below rear of center console.
Heated Oxygen Sensor (HO2S) "A" (B1S1)	Rear of engine, on right exhaust down pipe.
Heated Oxygen Sensor (HO2S) "B" (B2S1)	Rear of engine, on left exhaust down pipe.
Heated Oxygen Sensor (HO2S) "C" (B1S2)	On exhaust system, rear of right catalytic converter.
Heated Oxygen Sensor (HO2S) "D" (B2S2)	On exhaust system, rear of left catalytic converter.
Intake Air Temperature (IAT) Sensor	On air intake assembly. See Fig. 1 .
Knock Sensor	On top of engine, below common chamber. See Fig. 2 .
Manifold Absolute Pressure (MAP) Sensor	On top rear of intake manifold. See Fig. 1 .
Mass Airflow (MAF) Sensor	Left front corner of engine compartment. See Fig. 1 .
Rear Speed Sensor (Transfer)	On lower rear of transfer case.
Throttle Position (TP) Sensor	On air intake assembly. See Fig. 1 .
Transmission Speed Sensor	On top rear of transmission.
Thermo Unit	On left front of engine.
Vehicle Speed Sensor (VSS)	On underside of vehicle, right rear of front transfer case.

Isuzu VehiCROSS 1999 - SOLENOIDS & SOLENOID VALVES

Isuzu VehiCROSS 1999 SOLENOIDS & SOLENOID VALVES

Component	Component Location
Clutch Solenoid (Transfer)	In transfer case.
Evaporative Emission (EVAP) Canister Cut Valve	On underside of vehicle, above right side of rear axle.
Evaporative Emission (EVAP) Canister Purge Valve	On top left side of intake manifold. See Fig. 5 .
Exhaust Gas Recirculation (EGR) Solenoid Valve	On right rear of engine. See Fig. 1 .
Intake Air Vacuum Switching Valve	On left rear of engine.
Shift Lock Solenoid	Below front console, forward of gear selector.

Isuzu VehiCROSS 1999 - SWITCHES

Isuzu VehiCROSS 1999 SWITCHES

Component	Component Location
A/C Triple Pressure Switch	Behind left side of radiator grille.
Automatic Transmission Mode Switch	Left side of transmission.
Brake Fluid Level Switch	Left rear of engine compartment, on brake fluid reservoir.
Brake Switch	Behind dash, on brake pedal support.
Driver's Seat Belt Switch	In driver's seat belt buckle.
Kickdown Switch	On accelerator pedal bracket.
Oil Pressure Switch	Lower front of engine, at oil filter.
Park Position Switch	Below front console, at base of gear selector.
Parking Brake Switch	Below center console, at base of park brake lever.
Power Steering Pressure (PSP) Switch	Lower left front of engine compartment.
4H/L Transfer Switch Assembly	On bottom front of transfer case.

Isuzu VehiCROSS 1999 - MISCELLANEOUS

Isuzu VehiCROSS 1999 MISCELLANEOUS

Component	Component Location
Blower Resistor	Behind glove box.
Condenser (Ignition)	Top right front of engine.
Data Link Connector (DLC)	Left side of dash, near engine hood release.
Ignition Coils (6)	On respective valve covers, top of cylinders. See Fig. 4 .
Noise Suppression Filter No. 1	Behind left kick panel.
Noise Suppression Filter No. 2	Center of rear roof panel.

Isuzu VehiCROSS 1999 - CONNECTORS

Isuzu VehiCROSS 1999 CONNECTORS

Component	Component Location
B16 (Clear, 1 Pin)	Behind front console.
B18 (Clear, 2 Pin)	Behind front console.
B33 (Clear, 2 Pin)	Behind center of dash.
B38 (Black, 2 Pin)	Behind front console.
B43 (White, 2 Pin)	At right side of dash.
B44 (White, 6 Pin)	At right side of dash.
C9 (Black, 2 Pin)	At lower rear of right headlight assembly.
C37 (Black, 4 Pin)	Behind lower left of dash.
C38 (White, 16 Pin)	Behind lower left dash, right of steering column.
C40 (Brown, 8 Pin)	Behind lower left of dash, right of steering column.
C42 (Black, 14 Pin)	Behind lower left of dash, right of steering column.
C47 (Black, 6 Pin)	Below rear of center console.
C48 (White, 6 Pin)	Below center console.
C49 (Black, 2 Pin)	Below rear of center console.
C56 (Black, 2 Pin)	Behind front grille, below condenser fan.
D6 (Gray, 3 Pin)	Behind trim panel, in front of left door.
D7 (Gray, 4 Pin)	In front of left door, behind trim panel.
D8 (White, 3 Pin)	Behind trim panel, on lower rear of left door.
D15 (Gray, 3 Pin)	Behind trim panel, in front of right door.
D16 (Gray, 4 Pin)	In front of right door, behind trim panel.
E3 (Black, 1 Pin)	At lower left side of engine compartment.
E4 (Gray, 1 Pin)	At lower left side of engine compartment.
E9 (White, 7 Pin)	Taped to harness, on left front of engine.
E45 (Black, 1 Pin)	At top right front of engine.
F2 (Brown, 2 Pin)	Above right side of rear differential.
F3 (Black, 2 Pin)	Above right side of rear differential.
F4 (Black, 2 Pin)	Beneath rear of vehicle, right of fuel tank.
G6 (Black, 1 Pin)	On tailgate.
G8 (Black, 1 Pin)	On tailgate.
G10 (White, 2 Pin)	In tailgate.
G11 (White, 2 Pin)	In tailgate.
H1 (Black, 1 Pin)	On bracket, at right side of engine compartment.
H2 (Gray, 2 Pin)	On bracket, at right side of engine compartment.
H3 (Black, 2 Pin)	On bracket, at right side of engine compartment.
H4 (Blue, 16 Pin)	On bracket, at left rear of engine compartment.
H5 (Green, 16 Pin)	On bracket, at left rear of engine compartment.
H6 (Black, 16 Pin)	On bracket, at left rear of engine compartment.
H7 (Black, 16 Pin)	At lower left front of engine compartment.
H8 (Blue, 6 Pin)	At lower left front of engine compartment.
H9 (Green, 16 Pin)	At lower left front of engine compartment.
H10 (Clear, 6 Pin)	Below left side of dash, above kick panel.
H12 (White, 3 Pin)	Behind right side of dash.
H13 (White, 22 Pin)	On bracket, above left front kick panel.
H14 (Blue, 22 Pin)	On bracket, above left front kick panel.
H15 (Black, 18 Pin)	On bracket, above left front kick panel.
H16 (White, 20 Pin)	Under right front seat.
H18 (White, 20 Pin)	Behind right side dash panel.
H19 (White, 22 Pin)	Behind right side dash panel.
H20 (White, 15 Pin)	On bracket, above left front kick panel.
H21 (White, 8 Pin)	In access hole, behind left front kick panel.
H21A (Black, 13 Pin)	In access hole, behind left front kick panel.
H23 (Black, 13 Pin)	Below center console.
H24 (White, 8 Pin)	Behind right kick panel.
H25 (White, 6 Pin)	Behind right kick panel.
H26 (White, 4 Pin)	At left rear of cargo compartment, behind trim panel.
H27 (White, 9 Pin)	On right side of third crossmember.
H28 (Gray, 3 Pin)	At left rear of engine compartment.
H29 (White, 8 Pin)	On bracket, above left front kick panel.
J1 (Clear, 2 Pin)	Below front of console.
L2 (White, 2 Pin)	Above center of roof
M6 (Black, 5 Pin)	On left side of transmission.
M7 (Gray, 4 Pin)	On left side of transmission.
M17 (Black, 4 Pin)	On right front side of transmission.
M18 (Black, 4 Pin)	On left front side of transmission.
M19 (Black, 4 Pin)	On right rear of transmission.
M20 (Black, 4 Pin)	On left rear side of transmission.
M25 (Black, 8 Pin)	On left side of transmission.
M27 (Black, 12 Pin)	On top of transfer case.
R1 (Clear, 1 Pin)	In left door pillar, behind left door switch.
R5 (Black/White, 2 Pin)	Under left front seat.
R10 (Clear, 1 Pin)	In right door pillar, behind right door switch.
R15 (White, 6 Pin)	At left rear of cargo compartment, behind trim panel.
R17 (White, 6 Pin)	At right rear of cargo compartment, behind trim panel.
R22 (White, 2 Pin)	At center of rear roof panel, behind trim panel.
R22A (White, 2 Pin)	At center of rear roof panel, behind trim panel.

Isuzu VehiCROSS 1999 - GROUNDS

Isuzu VehiCROSS 1999 GROUNDS

Component	Component Location
B11	Below right side of front console.
C16	On inner fender panel, at left rear of engine compartment.
C31	Behind right kick panel.
C39	Behind left kick panel.
C46	At top left rear of engine.
E28	Top left rear of engine
E30	Top right rear of engine.
P6	On rear of battery tray, at lower right front of engine compartment.
P7	On frame rail, at lower right front of engine compartment.
P10	Above alternator, at lower right side of engine.
P15	On shift lever plate, on top of transmission.