2004 ISUZU Rodeo

Isuzu Rodeo S 2004 - BUZZERS, RELAYS & TIMERS

Isuzu Rodeo S 2004 BUZZERS, RELAYS & TIMERS LOCATION

Component	Location
Accessory Socket Relay	In dash fuse box. See Fig. 59 .
A/C Compressor Relay	In fuse/relay box. See Fig. 9 .
Condenser Fan Relay (3.2L)	In fuse/relay box. See Fig. 13 .
ECM Main Relay	In fuse/relay box. See Fig. 10 .
Flasher Unit	Above left kick panel. See Fig. 66 .
Fog Light Relay	In fuse/relay box. See Fig. 10 .
Fuel Pump Relay	In fuse/relay box. See Fig. 9 .
Headlight Relay	In fuse/relay box. See Fig. 13 .
Heater-A/C Relay	In fuse/relay box. See Fig. 9 .
Intake Actuator Relay	Behind glove box. See Fig. 123 .
Power Window Relay	On dash fuse box. See Fig. 59 .
Rear Defogger Relay	In dash fuse box. See Fig. 59 .
Shift Lock Relay	Under center console, below shift lever cover. See Fig. 79 .
Starter Relay	In fuse/relay box. See Fig. 13 .
Taillight Relay	On dash fuse box. See Fig. 60 .
Thermo Switch Relay	In fuse/relay box. See Fig. 10 .

Isuzu Rodeo S 2004 - CIRCUIT PROTECTION DEVICES

Isuzu Rodeo S 2004 CIRCUIT PROTECTION DEVICES LOCATION

Component	Location
Dash Fuse Box	Behind left side of dash, behind panel. See Fig. 58 .
Diode Box "B"	In fuse/relay box. See Fig. 9 .
Diode Box No. 5	In dash fuse box. See Fig. 60 .
Diode Box No. 6	In dash fuse box. See Fig. 60 .
Fuse/Relay Box	On right side of engine compartment. See Fig. 8 .
Option Box	At right side of engine compartment. See Fig. 55 .

Isuzu Rodeo S 2004 - CONTROL UNITS

Isuzu Rodeo S 2004 CONTROL UNITS LOCATION

Component	Location
Alarm & Relay Control Unit	Behind right side of dash, above right kick panel. See Fig. 78 .
Electronic Brake Control Module (EBCM)	On right rear corner of engine compartment. See Fig. 11 .
Engine Control Module (ECM) (3.2L)	Left rear of engine compartment. See Fig. 26 .
Engine Control Module (ECM) (3.5L DI)	Left side of engine compartment. See Fig. 43 .
Fuel Pump Controller	Left rear frame rail. See Fig. 53 .
Immobilizer Control Unit	Below center of dash. See Fig. 64 .
Ion Sensing Module (3.2L)	On top of intake manifold. See Fig. 20 .
Keyless Entry & Anti-Theft Control Unit	Behind right side of dash, above kick panel. See Fig. 78 .
Sensing & Diagnostic Module	Below center of dash. See Fig. 74 .
Sunroof Control Unit	Center front of roof, behind headliner. See Fig. 83 .
Tire Pressure Monitor Receiver	Under rear of console. See Fig. 127 .
Transfer Control Unit	Below center console. See Fig. 81 .
Transmission Control Module	Under left side of dash. See Fig. 73 .

Isuzu Rodeo S 2004 - MOTORS

Isuzu Rodeo S 2004 MOTORS LOCATION

Component	Location
Blower Motor	Below right side of dash. See Fig. 124 .
Condenser Fan	Behind right side of radiator grille. See Fig. 34 .
Front Axle Motor Actuator	On left side of front axle. See Fig. 110 .
Intake Actuator	On heater case. See Fig. 123 .
Power Window Motor (Left Front)	In left front door. See Fig. 87 .
Power Window Motor (Left Rear)	In left rear door. See Fig. 91 .
Rear Washer Motor	On right front of engine compartment, in washer fluid reservoir. See Fig. 31 .
Rear Wiper Motor	In center of tailgate. See Fig. 102 .
Recline Motor (Driver's)	Under driver's seat. See Fig. 121 .
Slide Motor (Driver's)	Under driver's seat. See Fig. 120 .
Starter	Bottom left side of engine. See Fig. 22 .
Sunroof Motor	Center front of roof. See Fig. 83 .
Transfer Actuator (A/T)	On rear of transmission. See Fig. 122 .
Transfer Actuator (M/T)	Beneath center of vehicle, on transfer case. See Fig. 119 .
Windshield Washer Motor	On right front of engine compartment, in washer fluid reservoir. See Fig. 31 .
Windshield Wiper Motor	On right rear corner of engine compartment, on firewall. See Fig. 7 .

Isuzu Rodeo S 2004 - SENDING UNITS & SENSORS

Isuzu Rodeo S 2004 SENDING UNITS & SENSORS LOCATION

Component	Location
Accelerator Pedal Position Sensor	Above accelerator pedal. See Fig. 75 .
A/C Pressure Sensor (3.5L DI)	Left front of vehicle. See Fig. 4 .
Crankshaft Position (CKP) Sensor	On lower right side of engine. See Fig. 56 .
ECT Sensor (3.5L DI)	On rear of engine, in coolant manifold. See Fig. 47 .
Engine Coolant Temperature (ECT) Sensor (3.2L)	On right front of engine. See Fig. 19 .
Front Speed Sensors (2WD)	On inside of front wheels. See Fig. 126 .
Front Speed Sensors (4WD)	On inside of front knuckle spindles. See Fig. 1 .
Heated Oxygen Sensor (HO2S) (Bank 1 Sensor 1) (3.2L)	In right front exhaust pipe. See Fig. 99 .
Heated Oxygen Sensor (HO2S) (Bank 1 Sensor 1) (3.5L DI)	On right exhaust downpipe. See Fig. 51 .
Heated Oxygen Sensor (HO2S) (Bank 1 Sensor 2) (3.2L)	Rear of right catalytic converter. See Fig. 100 .
Heated Oxygen Sensor (HO2S) (Bank 1 Sensor 2) (3.5L DI)	Rear of right catalytic converter. See Fig. 52 .
Heated Oxygen Sensor (HO2S) (Bank 2 Sensor 1) (3.2L)	In left front exhaust pipe. See Fig. 97 .
Heated Oxygen Sensor (HO2S) (Bank 2 Sensor 1) (3.5L DI)	On left exhaust downpipe. See Fig. 49 .
Heated Oxygen Sensor (HO2S) (Bank 2 Sensor 2) (3.2L)	Rear of left catalytic converter. See Fig. 98 .
Heated Oxygen Sensor (HO2S) (Bank 2 Sensor 2) (3.5L DI)	Rear of left catalytic converter. See Fig. 50 .
High Fuel Pressure Sensor (3.5L DI)	On top of engine. See Fig. 37 .
Input Revolution Sensor (3.2L)	Left side of transmission. See Fig. 97 .
Input Revolution Sensor (3.5L DI)	Near left front exhaust downpipe. See Fig. 54 .
Intake Air Temperature (IAT) Sensor (3.2L)	In air duct assembly. See Fig. 29 .
Knock Sensor 1 (3.5L DI)	Top of engine. See Fig. 45 .
Knock Sensor 2 (3.5L DI)	Top of engine. See Fig. 45 .
Low Fuel Pressure Sensor (3.5L DI)	Left side of transmission. See Fig. 54 .
MAF/IAT Sensor (3.5L DI)	Left front of engine compartment. See Fig. 46 .
Manifold Absolute Pressure (MAP) Sensor (3.2L)	On top rear of intake manifold. See Fig. 20 .
Mass Airflow (MAF) Sensor (3.2L)	In air duct assembly. See Fig. 30 .
Oil Temp Sensor (Transmission) (3.2L)	Right side of transmission. See Fig. 99 .
Oil Temp Sensor (Transmission) (3.5L DI)	Right side of transmission. See Fig. 51 .
Output Revolution Sensor	On right side of automatic transmission. See Fig. 116 .
Rear Speed Sensor	Beneath rear of vehicle, on top of differential. See Fig. 117 .
Vehicle Speed Sensor	Underside of vehicle, on transmission. See Fig. 116 .
Vehicle Speed Sensor (M/T)	On rear of transmission. See Fig. 119 .

Isuzu Rodeo S 2004 - SOLENOIDS & SOLENOID VALVES

Isuzu Rodeo S 2004 SOLENOIDS & SOLENOID VALVES LOCATION

Component	Location
Door Lock Actuator (Left Front)	In left front door. See Fig. 88 .
Door Lock Actuator (Left Rear)	In left rear door. See Fig. 90 .
Evaporative Emission (EVAP) Canister Purge Valve (3.2L)	On front of engine. See Fig. 28 .
Evaporative Emission (EVAP) Canister Purge Valve (3.5L DI)	Left side of engine. See Fig. 42 .
Evaporative Emission (EVAP) Canister Vent Valve	Underneath vehicle, above rear axle. See Fig. 115 .
Exhaust Gas Recirculation (EGR) Solenoid Valve (3.2L)	On top right rear of engine. See Fig. 15 .
Fuel Injector No. 1 (3.2L)	Right side of engine. See Fig. 16 .
Fuel Injector No. 1 (3.5L DI)	Top right side of engine. See Fig. 38 .
Fuel Injector No. 2 (3.2L)	Left side of engine. See Fig. 23 .
Fuel Injector No. 2 (3.5L DI)	Top left side of engine. See Fig. 41 .
Fuel Injector No. 3 (3.2L)	Right side of engine. See Fig. 16 .
Fuel Injector No. 3 (3.5L DI)	Top right side of engine. See Fig. 38 .
Fuel Injector No. 4 (3.2L)	Left side of engine. See Fig. 23 .
Fuel Injector No. 4 (3.5L DI)	Top left side of engine. See Fig. 41 .
Fuel Injector No. 5 (3.2L)	Right side of engine. See Fig. 16 .
Fuel Injector No. 5 (3.5L DI)	Top right side of engine. See Fig. 38 .
Fuel Injector No. 6 (3.2L)	Left side of engine. See Fig. 23 .
Fuel Injector No. 6 (3.5L DI)	Top left side of engine. See Fig. 41 .
Oil Control Valve (Left) (3.5L DI)	Front of left cylinder head. See Fig. 48 .
Oil Control Valve (Right) (3.5L DI)	Front of right cylinder head. See Fig. 48 .
Shift Lock Solenoid	Below shift lever cover. See Fig. 79 .
Tailgate Door Lock Actuator	At center of tailgate. See Fig. 103 .
Variable Intake Manifold Vacuum Switching Valve (3.2L)	On left rear of engine. See Fig. 24 .
Variable Intake Manifold Vacuum Switching Valve (3.5L DI)	Top left side of engine. See Fig. 42 .

Isuzu Rodeo S 2004 - SWITCHES

Isuzu Rodeo S 2004 SWITCHES LOCATION

Component	Location
A/C Dual Pressure Switch (3.2L M/T)	Behind left side of radiator grille. See Fig. 4 .
A/C Triple Pressure Switch (3.2L A/T)	Behind left side of radiator grille. See Fig. 4 .
Automatic Transmission Mode Switch (3.2L)	Right side of transmission. See Fig. 99 .
Automatic Transmission Mode Switch (3.5L DI)	On right side of transmission. See Fig. 51 .
Brake Fluid Level Switch	On left rear of engine compartment, in brake fluid reservoir. See Fig. 5 .
Brake Switch	Behind left side of dash, on brake pedal support. See Fig. 68 .
Clutch Start Switch	Behind left side of dash, on clutch pedal support. See Fig. 65 .
Clutch Switch	Behind left side of dash, on clutch pedal support. See Fig. 65 .
Door Actuator Position Switch (Left Rear)	Inside rear of left rear door, near actuator. See Fig. 90 .
Door Actuator Position Switch (Right Front)	Inside rear of right front door, near actuator. See Fig. 89 .
Door Key Detect & Actuator Position Switches (Left Front)	Inside rear of left front door, on key cylinder. See Fig. 89 .
Door Key Detect Switch (Left Front)	In left front door. See Fig. 88 .
Engine Hood Switch	At right rear corner of engine compartment. See Fig. 7 .
Front Door Switch	At respective front door striker. See Fig. 92 .
Hatch Gate Open Switch	Inside top center of tailgate, on latch assembly. See Fig. 101 .
Oil Pressure Switch (3.2L)	On lower front of engine, near oil filter. See Fig. 27 .
Parking Brake Switch	Beneath center console, on parking brake lever. See Fig. 81 .
Parking Position Detect Switch	Below shift lever cover. See Fig. 71 .
Rear Door Switch	On left "C" pillar. See Fig. 93 .
Tailgate Key Detect Switch	In center of tailgate. See Fig. 102 .
4WD Transfer Switch	On transfer case. See Fig. 107 .

Isuzu Rodeo S 2004 - MISCELLANEOUS

Isuzu Rodeo S 2004 MISCELLANEOUS LOCATION

Component	Location
Anti-Theft Horn	On right rear corner of engine compartment. See Fig. 7 .
Blower Resistor	Below right side of dash. See Fig. 124 .
Condenser (3.2L)	On right front of engine. See Fig. 19 .
Condenser (3.5L DI)	On top front of engine. See Fig. 45 .
Converter	Under vehicle, behind left rear wheel. See Fig. 112 .
Data Link Connector (DLC)	Below left side of dash, near engine hood release. See Fig. 61 .
Electronic Thermostat	Behind glove box, on plenum. See Fig. 124 .
Generator	Lower right front of engine. See Fig. 32 .
High Note Horn	Behind right side of radiator grille. See Fig. 35 .
Ignition Coil No. 1 (3.2L)	Right side of engine. See Fig. 17 .
Ignition Coil No. 1 (3.5L DI)	Right side of engine. See Fig. 39 .
Ignition Coil No. 2 (3.2L)	Left side of engine. See Fig. 21 .
Ignition Coil No. 2 (3.5L DI)	Left side of engine. See Fig. 40 .
Ignition Coil No. 3 (3.2L)	Right side of engine. See Fig. 17 .
Ignition Coil No. 3 (3.5L DI)	Right side of engine. See Fig. 39 .
Ignition Coil No. 4 (3.2L)	Left side of engine. See Fig. 21 .
Ignition Coil No. 4 (3.5L DI)	Left side of engine. See Fig. 40 .
Ignition Coil No. 5 (3.2L)	Right side of engine. See Fig. 17 .
Ignition Coil No. 5 (3.5L DI)	Right side of engine. See Fig. 39 .
Ignition Coil No. 6 (3.2L)	Left side of engine. See Fig. 21 .
Ignition Coil No. 6 (3.5L DI)	Left side of engine. See Fig. 40 .
Immobilizer Antenna Coil	In right side of steering column, around ignition lock cylinder. See Fig. 57 .
J/C A	In fuse/relay box. See Fig. 14 .
J/C B	In fuse/relay box. See Fig. 14 .
Low Note Horn	Behind right side of radiator grille. See Fig. 35 .
Trailer Harness Connector	In left "D" pillar, behind trim. See Fig. 111 .

Isuzu Rodeo S 2004 - CONNECTORS

Isuzu Rodeo S 2004 CONNECTORS LOCATION

Component	Location
B-9 (Black, 6 Pin)	In right taillight assembly. See Fig. 105 .
B-13 (Black, 6 Pin)	In left taillight assembly. See Fig. 105 .
B-22 (White, 2 Pin)	Under driver's seat. See Fig. 120 .
B-38 (White/Gray, 2 Pin)	Under driver's seat. See Fig. 120 .
B-39 (White/Gray, 2 Pin)	Under passenger's seat. See Fig. 120 .
C-13 (Brown, 2 Pin)	Behind left front wheel. See Fig. 2 .
C-17 (Gray, 2 Pin)	Behind left side of front bumper. See Fig. 3 .
C-22 (Gray, 2 Pin)	Behind right side of front bumper. See Fig. 3 .
C-24 (Gray, 2 Pin)	Near condenser fan. See Fig. 34 .
C-27 (White, 6 Pin)	At right rear of engine compartment, on wiper motor assembly. See Fig. 7 .
C-33 (Brown, 2 Pin)	Behind right front wheel. See Fig. 2 .
C-47 (3.2L) (Gray, 4 Pin)	At lower left side of engine. See Fig. 70 .
D-2 (White, 2 Pin)	Behind trim, inside front of left front door. See Fig. 87 .
D-3 (White, 8 Pin)	At top front of left front door. See Fig. 86 .
D-9 (Black, 3 Pin)	Inside rear of left front door. See Fig. 88 .
D-11 (White, 2 Pin)	Inside front of right front door. See Fig. 87 .
D-12 (White, 8 Pin)	Top front of right front door. See Fig. 86 .
D-15 (Black, 3 Pin)	Inside rear of right front door. See Fig. 88 .
D-20 (White, 2 Pin)	Inside front of left rear door. See Fig. 91 .
D-25 (White, 2 Pin)	Inside front of right rear door. See Fig. 91 .
E-2 (3.5L DI) (Black, 1 Pin)	Lower left side of engine. See Fig. 6 .
E-3 (3.2L) (Black, 1 Pin)	At left side of engine. See Fig. 6 .
E-3 (3.5L DI) (Black, 1 Pin)	Lower left side of engine. See Fig. 6 .
E-4 (3.2L) (Gray, 1 Pin)	At left side of engine compartment. See Fig. 6 .
E-9 (3.2L) (Gray, 7 Pin)	At left side of engine compartment, fastened to harness. See Fig. 29 .
E-45 (3.2L) (Black, 1 Pin)	At front of engine, near throttle body. See Fig. 19 .
E-50 (White, 4 Pin)	At left front of transmission. See Fig. 97 .
E-51 (White, 4 Pin)	At right front of transmission. See Fig. 99 .
E-56 (White, 1 Pin)	On transfer case. See Fig. 106 .
E-57 (White, 1 Pin)	On transfer case. See Fig. 106 .
E-58 (White, 4 Pin)	At left rear of transmission. See Fig. 98 .
E-59 (White, 4 Pin)	At right rear of transmission. See Fig. 100 .
E-60 (Gray, 6 Pin)	Underneath center of vehicle, rear of transfer case. See Fig. 119 .
F-4 (Gray, 2 Pin)	Under center rear of vehicle. See Fig. 117 .
G-1 (White, 2 Pin)	Behind trim, on tailgate. See Fig. 104 .
G-5 (Black, 3 Pin)	Behind trim, on tailgate. See Fig. 102 .
G-6 (White, 6 Pin)	Behind trim, on tailgate. See Fig. 102 .
G-8 (Gray, 2 Pin)	Under right side of rear bumper. See Fig. 109 .
H-1 (White, 1 Pin)	At right side of engine compartment, on fuse/relay box. See Fig. 14 .
H-2 (Gray, 2 Pin)	At right side of engine compartment, on fuse/relay box. See Fig. 18 .
H-3 (3.5L DI) (Gray, 32 Pin)	Left side of engine compartment. See Fig. 43 .
H-4 (3.2L) (Gray, 52 Pin)	At left side of engine compartment. See Fig. 33 .
H-7 (Black, 16 Pin)	At left side of engine compartment. See Fig. 33 .
H-11 (Gray, 6 Pin)	Behind right kick panel. See Fig. 82 .
H-12 (Blue, 6 Pin)	Behind right kick panel. See Fig. 80 .
H-13 (White, 20 Pin)	Behind right kick panel. See Fig. 82 .
H-14 (Black, 19 Pin)	Behind right kick panel. See Fig. 82 .
H-15 (3.5L DI) (Blue, 15 Pin)	Behind left kick panel. See Fig. 63 .
H-16 (Black, 22 Pin)	Behind left kick panel. See Fig. 62 .
H-17 (2.5L DI) (Black, 19 Pin)	Behind left kick panel. See Fig. 62 .
H-18 (White, 22 Pin)	Behind right kick panel. See Fig. 80 .
H-19 (W/O Separate Amp) (Black, 6 Pin)	Behind right kick panel. See Fig. 80 .
H-19 (W/Separate Amp) (Black, 12 Pin)	Behind right kick panel. See Fig. 80 .
H-20 (White, 1 Pin)	At right side of rear roof panel, behind trim. See Fig. 95 .
H-21(White, 2 Pin)	Behind trim, at left side of rear roof panel. See Fig. 96 .
H-22 (White, 8 Pin)	Behind trim, at lower left "D" pillar. See Fig. 94 .
H-24 (White, 10 Pin)	At left "B" pillar, behind trim. See Fig. 92 .
H-25 (White, 15 Pin)	Under driver's seat, below carpet. See Fig. 72 .
H-27 (Gray, 2 Pin)	Underneath left rear of vehicle. See Fig. 114 .
H-28 (W/O Power Windows) (White, 4 Pin)	Rear of right front inner wheel well. See Fig. 108 .
H-28 (W/Power Windows) (White, 22 Pin)	Rear of right front inner wheel well. See Fig. 108 .
H-29 (White, 10 Pin)	Behind trim, on right "B" pillar. See Fig. 92 .
H-30 (White, 8 Pin)	Behind left side of dash, above kick panel. See Fig. 69 .
H-31 (White, 22 Pin)	Behind left kick panel. See Fig. 63 .
H-32 (White, 16 Pin)	Behind left kick panel. See Fig. 62 .
H-33 (W/O Power Windows) (White, 4 Pin)	Above right kick panel, in door grommet. See Fig. 108 .
H-33 (W/Power Windows) (White, 22 Pin)	Above right kick panel, in door grommet. See Fig. 108 .
H-34 (White, 8 Pin)	On lower left "D" pillar, behind trim. See Fig. 94 .
H-47 (Brown, 10 Pin)	Behind left kick panel. See Fig. 62 .
H-48 (3.2L) (Black, 16 Pin)	Left front of engine compartment. See Fig. 36 .
H-48 (3.5L DI) (Gray, 8 Pin)	Left front of engine compartment. See Fig. 44 .
H-49 (3.2L) (Gray, 16 Pin)	At front left side of engine compartment. See Fig. 36 .
H-49 (3.5L DI) (White, 16 Pin)	Left front of engine compartment. See Fig. 44 .
I-13 (Yellow, 2 pin)	Behind left side of dash, on connector bracket. See Fig. 67 .
I-25 (Yellow, 2 Pin)	Behind glove box. See Fig. 77 .
I-31 (White, 13 Pin)	Behind left side of dash, on connector bracket. See Fig. 67 .
I-32 (White, 20 Pin)	Behind left side of dash, on connector bracket. See Fig. 66 .
I-33 (White, 8 Pin)	Behind center side of dash. See Fig. 113 .
I-40 (White, 6 Pin)	Below front of center console. See Fig. 118 .
I-46 (White, 8 Pin)	Behind left side of dash, on connector bracket. See Fig. 67 .
J-3 (White, 2 Pin)	Behind headliner, at center front of roof. See Fig. 84 .
L-1 (White, 2 Pin)	Behind headliner, at center front of roof. See Fig. 84 .
L-4 (Black, 2 Pin)	In headliner, behind fastener for left vanity mirror. See Fig. 85 .
L-6 (Black, 2 Pin)	In headliner, behind fastener for right vanity mirror. See Fig. 85 .
M-25 (Gray, 2 Pin)	On right side of transmission. See Fig. 125 .
M-26 (Brown, 2 Pin)	On right side of transmission. See Fig. 125 .

Isuzu Rodeo S 2004 - GROUNDS

Isuzu Rodeo S 2004 GROUNDS LOCATION

Component	Location
B-99	At right rear floor of cargo area. See Fig. 76 .
C-16 (3.2L)	At left rear corner of engine compartment, on inner fender panel. See Fig. 25 .
C-16 (3.5L DI)	Left rear of engine compartment. See Fig. 43 .
C-36	At right side of engine compartment, behind battery. See Fig. 12 .
E-21	Top front of engine. See Fig. 37 .
E-23	Top front of engine. See Fig. 37 .
E-28 (3.2L)	At left side of intake manifold. See Fig. 24 .
E-29	At left side of intake manifold. See Fig. 24 .
E-30	At right side of intake manifold. See Fig. 15 .
I-43	Below left side of dash, above kick panel. See Fig. 63 .
P-2	In fuse/relay box. See Fig. 14 .
P-6	At right side of engine compartment, behind battery. See Fig. 12 .
P-10	At lower right front of engine. See Fig. 12 .
P-11	In fuse/relay box. See Fig. 14 .