AIR CONDITIONING – Dodge Pickup R3500 2005 – SYSTEM WIRING DIAGRAMS

AIR CONDITIONING

Manual A/C Wiring Diagram (1 of 2) for Dodge Pickup R3500 2005

List of elements for Manual A/C Wiring Diagram (1 of 2) for Dodge Pickup R3500 2005:

• (at left front fender) integrated power module
• (behind right side of dash) blower motor
• (left side of dash)
• (left side of engine compt)
• (not used)
• (right side of hvac) s224
• (right side of hvac) s226
• (w/o dual zone a/c) (on hvac unit)
• 87a
• A/c compressor clutch relay (single zone)
• A/c indicator
• A/c select
• A/c-heater control
• Acc
• Blend door driver
• Blower motor relay
• Blower motor resistor (behind right side of dash)
• Common door driver
• Condenser fan relay
• Connector
• Data link
• Driver blend door actuator (w/ dual zone a/c) blend door actuator
• Evaporator temperature sensor (right side of hvac)
• Except srt-10
• Fuse 10a
• Fuse 30a
• G104
• G201 (left side of dash)
• G203 (center of dash)
• Heated mirror
• Heated mirror relay
• Heater mirror indicator
• High
• Hot at all times
• Hot in run
• Hot in run or start
• Hvac micro controller
• Ignition switch (left side of steering column)
• Instrument cluster
• Lock
• Low
• Mode door actuator 1
• Mode door actuator 2
• Off
• Panel lamps driver
• Pass blend door driver
• Passenger blend door actuator (right side of dash)
• Ptc 1 7.5a
• Recirc
• Recirculation door actuator (on hvac unit)
• Recirculation door driver
• Recirculation indicator
• Run
• S113 (rear of engine compt)
• S147 (left side of engine compt)
• S191
• S225 (w/ adjustable pedal) (behind left side of dash)
• S230 (behind right side of dash)
• Sensor ground
• Sensor signal
• Srt-10
• Start
• W/ dual zone a/c

Manual A/C Wiring Diagram (2 of 2) for Dodge Pickup R3500 2005

List of elements for Manual A/C Wiring Diagram (2 of 2) for Dodge Pickup R3500 2005:

• (3.7l & 4.7l: right of generator) (8.3l: front of engine) (diesel) engine coolant temperature sensor
• (4.7l: top front of transmission (5.7l: at rear of engine) (except srt-10) s130 s131 (srt-10) (top left of engine)
• (5.7l: in engine harness, at right rear of engine) (4.7l: top center of dash) (except srt-10) s150
• (except 5.7l)
• (left side of engine)
• (right side of engine compt) (srt-10) g110
• (top of transmission)
• A/c compressor clutch (front of a/c compressor)
• A/c press sig
• A/c pressure signal
• A/c pressure transducer (3.7l & 4.7l: top front of engine) (5.7l: above a/c compressor) (5.9l: left side of a/c compressor)
• Actuator)
• At sig
• C13
• C918
• Condenser fan motor (left front of engine compt)
• Control
• D25
• Data link connector (left side
• Diesel
• Ect sig
• Engine control module (diesel) (lower left front of engine block)
• Engine coolant temperature sensor (3.7l & 4.7l: right of generator) (8.3l: front of engine)
• Except srt-10
• F855 (or 856)
• G104 (rwal)
• G106 (awal) (left rear of engine compt)
• G107 (except srt-10)
• G120
• Gas
• K173
• K900
• Of dash)
• Pci bus
• Pnk/ f855
• Powertrain control module (right rear of engine compartment)
• Red/ k914
• Relay
• Relay ctrl
• S131 (top left of engine)
• S132 s135 (5.7l) (behind left side of dash)
• S157 (near breakout for camshaft position sensor)
• S176 (near breakout for fuel control actuator)
• S182 (srt-10 a/t) (right rear of engine compt)
• S195 (left rear of engine compartment)
• Sensor gnd
• Signal
• Srt-10
• Tan/ k2