Chevrolet Cobalt 2005 - 2005 ELECTRICAL Fuses & Circuit Breakers - Cobalt
Chevrolet Cobalt 2005 - IDENTIFICATION
CAUTION: When battery is disconnected, vehicle computer and memory systems may lose memory data. Driveability problems may exist until computer systems have completed a relearn cycle. See appropriate COMPUTER RELEARN PROCEDURES article in GENERAL INFORMATION before disconnecting battery.
Chevrolet Cobalt 2005 - FUSIBLE LINK
Fusible links are usually located between battery and starter or electrical center. For description and repair procedures, see Fig. 1.
Fig. 1: Chevrolet Cobalt 2005 - Component Locations - Repairing Fusible Links
Chevrolet Cobalt 2005 - BODY CONTROL MODULE FUSE BLOCK
NOTE: Body Control Module is located under center of instrument panel below radio on right side of center console.
Chevrolet Cobalt 2005 Body Control Module (BCM) Usage
No. Device Rating Description 1 FUSE PULLER - - 2 SPARE - Not Used 3 SPARE - Not Used 4 SPARE - Not Used 5 SPARE - Not Used 6 AMP Fuse 20A Audio Amplifier (UQ3) 7 CLSTR Fuse 10A Instrument Panel Cluster (IPC) 8 IGN SW Fuse 2A Ignition Switch 9 STOP LP Fuse 10A Stop Lamp Switch 10 HVAC/PK3 Fuse 10A HVAC Control Module 11 EMPTY - Not Available 12 SPARE 20A Not Used 13 AIR BAG Fuse 10A Inflatable Restraints Sensing and Diagnostic Module (SDM) 14 SPARE 10A Not Used 15 WPR Fuse 10A Windshield Wiper/Washer Switch and Supercharger Boost Control Solenoid 16 HVAC/CLSTR/BTSI Fuse 10A Instrument Panel Cluster (IPC), Heated Seat Switch - Driver, Heated Seat Switch - Passenger, Clutch Pedal Start Switch, HVAC Control Module, Stop Lamp/TCC Switch 17 EMPTY - Not Available 18 EMPTY - Not Available 19 EPS/STR WHL CNRL Fuse 2A Electric Power Steering (EPS) Column Assembly, Inflatable Restraint Steering Wheel Module Control 20 S ROOF Fuse 15A Sunroof Switch, Inside Rearview Mirror(UE1) 21 SPARE 20A Not Used 22 EMPTY - Not Available 23 EMPTY - Not Available 24 SDM Fuse 10A Inflatable Restraint Sensing and Diagnostic Module (SDM), Body Control Module (BCM) 25 ECM/TCM Fuse 10A Fuse Block Underhood, Transmission Control Module (TCM)(L61), Engine Control Module (ECM)(L61), Powertrain Control Module (PCM) (LSJ) 26 DR LCK Fuse 15A Door Unlock Relays, Door Lock Relay, Interior Lamps Relay 27 INT LIGHT Fuse 10A Interior Lamps Relay 28 RDO Fuse 10A Radio, Remote Control Door Lock Receiver (RCDLR) (AUO) 29 PWR WNDW Fuse 30A Window Switch - Passenger, Window switch - Driver 30 IGN3 Relay - Blower Motor 31 EMPTY - Not Available 32 RAP Relay - Retained Accessory Power
Chevrolet Cobalt 2005 - FUSE HOLDER (50A)
Fuse Holder (50A) is located in rear compartment of vehicle near battery.
Chevrolet Cobalt 2005 - UNDERHOOD FUSE BLOCK
NOTE: Underhood fuse block is located in engine compartment next to left strut tower.
Fig. 3: Chevrolet Cobalt 2005 - Component Locations - Identifying Underhood Fuse Block
Chevrolet Cobalt 2005 Fuse Block - Underhood Usage
Device Rating Description EPS Fuse 60A Electric Power Steering Control Module ABS Fuse 50A Electronic Brake Control Module (EBCM) BCM 2 Fuse 40A Body Control Module (BCM) BCM 3 Fuse 30A Body Control Module (BCM) HTD SEATS Fuse 20A Heated Seat Module - Driver, Heated Seat Module - Passenger S BAND/ONSTAR Fuse 10A Vehicle Communication Interface Module (VCIM) (UE1), Digital Radio Receiver (U2K) LIGHTER Fuse 15A Cigar Lighter (DT4), Data Link Connector (DLC) CAN VENT Fuse 10A Evaporative Emission (EVAP) Canister Vent Soleniod MIRRORS Fuse 5A Outside Rearview Mirror Switch (DG7) COOLING FAN1 Fuse 30A Cooling Fan 1 Relay COOLING FAN2 Fuse 30A Cooling Fan 2 Relay HORN 10A Horn CRANK Fuse 30A Crank Relay PARK LPS Fuse 15A Lamp Assembly-LF, Lamp Assembly-RF Stop/Tail and Turn Signal Lamp-Left,Body Control Module (BCM), Side Marker Lamp-Left, Side Marker Lamp-Right, License Lamp, Stop/Tail and Turn Signal Lamp-Right RH LOW BEAM Fuse 10A Lamp Assembly - RF LH LOW BEAM Fuse 10A Lamp Assembly - LF RH HI BEAM Fuse 10A Lamp Assembly - RF LH HI BEAM Fuse 10A Lamp Assembly - LF WIPER Fuse 25A Wiper Relay I/P IGN Fuse 20A Body Control Module BACK UP Fuse 10A Park Neutral Position (PNP) Switch (MN5), Back Up Lamp Switch (L61/M86) ABS 2 Fuse 10A Electric Brake Control Module (EBCM) ECM/TRANS Fuse 15A Supercharger Boost Control Solenoid (LSJ), Transmission Control Module (TCM), Engine Control Module (ECM) (L61), Powertrain Control Module (PCM) (LSJ) TRUNK/OUTLET Fuse 20A Trunk Release Relay, Auxiliary Power Outlet- Console FUEL PUMP Fuse 15A Fuel Pump and Sender Assembly EMISSIONS Fuse 10A Heated Oxygen Sensor (HO2S) Sensor 1, Heated Oxygen Sensor (HO2S) Sensor 2, Evaporative Emission (EVAP) Canister Purge Solenoid, Clutch Pedal Position (CPP) Switch, Mass Air Flow (MAF). Inlet Air Temperature (IAT) Sensor INJECTORS Fuse 10A Fuel Injector 1, Fuel Injector 2, Fuel Injector 3, Fuel Injector 4, Ignition Coil/Module 1 (LSJ), Ignition Coil/Module 2 (LSJ), Ignition Coil/Module 3 (LSJ), Ignition Coil/Module 4 (LSJ), Ignition Control Module (ICM) (L61) PCM/ECM Fuse 15A Engine Control Module (ECM) (L61), Powertrain Control Module (PCM) (LSJ) AFTRCOOL Fuse 15A After Cooling Pump (LSJ) A/C CLUTCH Fuse 10A A/C Compressor Clutch (C60) REAR DEFOG Fuse 40A Rear Defog Relay FOG LP Fuse 15A Fog Lamp - LF, Fog Lamp - RF COOLING FAN 1 Relay - Cooling Fan COOL SER/PAR Relay - Cooling Fan (LSJ) COOLING FAN 2 Relay - Cooling Fan CRANK Relay - Starter WIPER 1 Relay - WIPER 2 relay, G101 WIPER 2 Relay - Windshield Wiper Motor RUN/CRANK Relay (L61) - ECM/TRANS Fuse, I/P IGN Fuse, BACK UP Fuse, ABS Fuse, RUN/CRANK Relay (LSJ) - I/P Fuse, FUTURE Fuse, BACK UP Fuse, ABS Fuse, ECM/TRANS Fuse FUEL PUMP Relay - Fuel Pump and Sender Assembly POWERTRAIN Relay (LSJ) - EMISSION Fuse, INJECTOR Fuse ECM Fuse, PCM Fuse AFTRCOOL Relay (LSJ) - AFTR COOL Fuse A/C CLUTCH Relay - A/C CLUTCH Fuse REAR DEFOG Relay - Rear window defogger grid