Chevrolet Malibu 2000 - 2000 GENERAL MOTORS Malibu

Chevrolet Malibu 2000 - BUZZERS, RELAYS & TIMERS

Chevrolet Malibu 2000 BUZZERS, RELAYS & TIMERS

Component	Component Location
A/C Compressor Clutch Relay	On underhood junction block.
Automatic Lamp Control Relay	On underhood junction block.
Blower Motor Relay	On underhood junction block.
Cooling Fan Mode Relay	On underhood junction block.
Daytime Running Lamps (DRL) Relay	On underhood junction block.
Door Lock Relay	On left I/P junction block.
Door Unlock Relay	On left I/P junction block.
Electronic Brake Control (ABS) Relay	Integral to electronic brake control module.
Fan Control Relay No. 1	On underhood junction block.
Fan Control Relay No. 2	On underhood junction block.
Fog Lamps Relay	On right I/P junction block.
Fuel Pump Relay	On underhood junction block.
Horn Relay	On underhood junction block.
Park Lamp Relay	On underhood junction block.
Rear Compartment Lid Release Relay	On left I/P junction block.
Rear Defogger Relay	On underhood junction block.

Chevrolet Malibu 2000 CIRCUIT PROTECTION DEVICES

Component	Component Location
Left I/P Junction Block	On left end of dash.
Power Seats Circuit Breaker	On left I/P junction block.
Power Windows Circuit Breaker	On right I/P junction block.
Right I/P Junction Block	On right end of dash. See Fig. 4 .
Underhood Junction Block	On left side of engine compartment.

Chevrolet Malibu 2000 CONTROL UNITS

Component	Component Location
Body Control Module (BCM)	Below right side of dash, near blower motor. See Fig. 4 .
Brake Pressure Modulator Valve (BPMV)	At lower left front of engine compartment.
Cruise Control Module	On right side of engine compartment. See Fig. 3 .
Electronic Brake Control Module (EBCM)	Inside left front fender.
Fuel Tank Module	Under rear of vehicle, at fuel tank.
Ignition Control Module	On top front of engine.
Inflatable Restraint Sensing & Diagnostic Module	Under right front seat.
Lamp Dimmer Module	On left side of dash.
Powertrain Control Module (PCM)	Below left side of dash, near steering column. See Fig. 2 .
Remote Control Door Lock Receiver	On rear package shelf.

Chevrolet Malibu 2000 MOTORS

Component	Component Location
Air Temperature Actuator	On top right side of dash.
Blower Motor	Below right side of dash. See Fig. 4 .
Cooling Fan Motor (Left/Right)	On front of engine compartment.
Forward-Back Motor	Under left front seat.
Front Height Motor	Under left front seat.
Rear Compartment Lid Release Motor	On rear compartment lid.
Rear Height Motor	Under left front seat.
Starter Motor	On lower left side of engine.
Sun Roof Assembly	On headliner.
Washer Motor	Between washer solvent reservoir & frame rail.
Wiper Motor Assembly	On left rear of engine compartment.

Chevrolet Malibu 2000 SENDING UNITS & SENSORS

Component	Component Location
A/C Refrigerant Pressure Sensor	On front of engine compartment.
Ambient Lamp Sensor	On top of dash trim pad.
Camshaft Position (CMP) Sensor (3.1L VIN M)	On front of engine. See Fig. 1 .
Crankshaft Position (CKP) Sensor (7X) (3.1L VIN M)	On lower right side of engine. See Fig. 1 .
Crankshaft Position (CKP) Sensor (24X)	On lower front of engine.
Engine Coolant Temperature (ECT) Sensor	On top rear of engine.
Engine Oil Pressure Sensor	On left side of engine.
Fuel Tank Pressure Sensor	Under rear of vehicle.
Intake Air Temperature (IAT) Sensor	In air intake duct, near throttle body.
Knock Sensor	On lower left side of engine.
Manifold Absolute Pressure (MAP) Sensor	Attached to bracket, on top of engine.
Mass Airflow (MAF) Sensor	On air intake duct assembly.
Passenger Safing Sensor	On right end of dash. See Fig. 4 .
Passlock Sensor	On left side of dash.
Post Converter Heated Oxygen Sensor (HO2S 2)	At rear of catalytic converter.
Pre-Converter Heated Oxygen Sensor (HO2S 1)	On right side exhaust manifold.
Pre-Converter Oxygen Sensor (O2S)	On exhaust manifold.
Throttle Position (TP) Sensor	On top rear of engine.
Vehicle Speed Sensor (VSS)	On rear of engine/transaxle.
Washer Solvent Level Sensor	Inside of left front fender.
Wheel Speed Sensor (4)	On respective wheel hub.

Chevrolet Malibu 2000 SOLENOIDS & SOLENOID VALVES

Component	Component Location
ABS Solenoids	Integral to brake pressure modulator valve.
AIR Solenoid Valve	On engine.
Evaporative Emission Canister Purge Valve	On top right rear of engine.
Evaporative Emission Canister Vent Solenoid	Under rear of vehicle.
Exhaust Gas Recirculation (EGR) Valve (3.1L VIN M)	On top rear of engine. See Fig. 1 .
Fuel Injectors	On top of engine.
Idle Air Control (IAC) Valve (3.1L VIN M)	On top center rear of engine. See Fig. 1 .
Starter Solenoid	On lower left side of engine, on starter motor.

Chevrolet Malibu 2000 SWITCHES

Component	Component Location
Brake Fluid Level Switch	On brake master cylinder reservoir.
Brake Switch	On brake pedal support.
Cruise Control Brake Switch	On brake pedal support.
Engine Coolant Level Switch	On engine coolant surge tank.
Engine Oil Level Switch	On engine oil pan.
Park Brake Switch	On park brake assembly.
Park/Neutral Position Switch	On side of transaxle.
Rear Compartment Lid Release Switch	Below left side of dash.
Seat Belt Switch	In driver's seat belt assembly.
Transaxle Range Switch	On side of transaxle.

Chevrolet Malibu 2000 MISCELLANEOUS

Component	Component Location
A/C Compressor Clutch	On lower left front of engine.
A/C Compressor Clutch Diode	In underhood junction block.
Auxiliary Power Outlet	On top right side of dash.
Blower Resistor Assembly	Below right side of dash. See Fig. 4 .
Data Link Connector (DLC)	Below left side of dash, near steering column. See Fig. 2 .
DRL Resistor	On rear of front impact bar.
Generator	On top front of engine.
Horn Assembly	Inside right front fender.
SIR Coil Assembly	On top of steering column.

Chevrolet Malibu 2000 CONNECTORS

Component	Component Location
C101 (Black, 10 Pin)	On left side of engine compartment.
C102 (Gray, 20 Pin)	On left side of engine.
C120 (2 Pin)	On top rear of engine.
C130 (Black, 10 Pin)	On top rear of engine.
C200 (Black, 18 Pin)	Below left side of dash, near steering column.
C300 (White, 10 Pin)	Below left side of dash, near steering column.
C301 (Black, 3 Pin)	In headliner.
C306 (Black, 2 Pin)	In left side of passenger compartment.
C400 (Natural, 8 Pin)	In left rear of passenger compartment.
C413 (16 Pin)	Under rear of vehicle.
C500 (Gray, 18 Pin)	In left front corner of passenger compartment.
C501 (Black, 18 Pin)	In left front of passenger compartment.
C600 (Black, 18 Pin)	In right front corner of passenger compartment.
C700 (Black, 7 Pin)	In left side of passenger compartment.
C800 (Black, 7 Pin)	In right side of passenger compartment.

Chevrolet Malibu 2000 GROUNDS

Component	Component Location
G101	On left side of engine compartment.
G102	On front of engine.
G103	On left side of engine.
G104	On left side of engine compartment.
G105	On left side of engine compartment.
G201	On left side of dash.
G202	On left side of dash.
G203	On right side of dash. See Fig. 4 .
G204	On right side of dash. See Fig. 4 .
G301	On left side of passenger compartment.
G302	On right side of passenger compartment.
G401	On left side of passenger compartment, on rear package shelf.
G402	On right side of passenger compartment, on rear package shelf.

Chevrolet Malibu 2000 SPLICES