ENGINE PERFORMANCE – Dodge Pickup R3500 1995 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

3.9L

3.9L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Pickup R3500 1995

List of elements for 3.9L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Pickup R3500 1995:

• (located in exhaust pipe)
• (right side of dash panel)
• A/c comp cl rly gnd
• A/c damped press sw
• A14
• A142
• Acc
• Air conditioning system
• Auto shutdown feed
• Auto shutdown relay
• Automatic shut down relay (in pwr dist ctr)
• B/h conn
• Brake sense
• C13
• C20
• Camshaft pos sensor
• Center
• Charge air temp
• Cluster system (fuel gauge)
• Control module
• Cruise control system
• D20
• D21
• Data link receive
• Data link transmit
• Direct battery
• Dist ign sensor (b+)
• Distribution
• Ect sensor
• Egr solenoid
• Egr solenoid (right rear of intake)
• Engine data
• Evap/purge solenoid
• Evap/purge solenoid (left rear of engine)
• F18
• Fuel
• Fuel pump relay (in pwr dist ctr)
• Fuel tank level gauge sending unit (top of fuel tank)
• Fuse 3 ign/acc 40a
• Fuse 4 eng 30a
• Fuse 8 fuel 20a
• Fuse 9 10a
• Fuse block: i/p
• G125
• G125 (below a/c compressor)
• G14
• G21
• Generator
• Heated oxygen sensor
• Hot at all times
• Htd oxygen sensor
• Iac motor
• Idle air control motor (on throttle body)
• Ign coil driver
• Ign feed
• Ignition coil (rear of engine)
• Ignition switch
• Inj driver 1
• Inj driver 2
• Inj driver 3
• Inj driver 4
• Inj driver 5
• Inj driver 6
• Injectors
• Instrument
• Instrument cluster system (message center)
• Instrument cluster system (tach)
• K11
• K12
• K13
• K14
• K19
• K20
• K21
• K22
• K24
• K35
• K38
• K39
• K40
• K41
• K44
• K51
• K52
• K54
• K58
• K59
• K60
• Link connector (right side cowl)
• Map sensor
• Mil
• Nca
• Off
• Pnk
• Power
• Power ground
• Powertrain
• Red
• Run
• Signal ref (b-)
• Start
• Starter rly
• T18
• T41
• T54
• T60
• Tach output
• Tan
• Tan/red
• Throttle position
• Trans ctrl
• Trans od solenoid
• Trans od sw feed
• Trans temp lamp
• Trans temp sensor
• V31
• V32
• V33
• V35
• V36
• V40
• Voltage reg
• Vs ctrl-ign
• Vs ctrl-resume/accel
• Vs ctrl-set/coast
• Vs ctrl-vacuum
• Vs ctrl-vent
• Vss
• Z12

3.9L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Pickup R3500 1995

List of elements for 3.9L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Pickup R3500 1995:

• (on throttle body)
• (on transmission)
• A/t only
• Anti-lock brakes system (abs controller)
• B/h conn
• C215
• C216
• Camshaft position sensor (in distributor)
• Check engine lamp
• Crankshaft position sensor (right rear of engine)
• Engine coolant temperature sensor (front of engine)
• Fuse 11 10a
• Fuse 12 15a
• Fuse block: i/p
• G206 (i/p left center support)
• Hot in run or start
• Instrument cluster
• Intake air temperature sensor (right front of intake)
• Joint connector c (behind knee bolster)
• Map sensor (mounted on throttle body)
• Pnk
• Speedo- meter
• Starter relay)
• Starting system (engine
• Stop lamp & vehicle speed control switch
• Throttle position sensor
• Transmission overdrive solenoid (mounted on transmission)
• Transmission overdrive switch
• Transmission range switch
• Transmission temperature sensor (in transmission cooler line)
• Upshift lamp
• Vehicle speed sensor (rear of transmission)

5.2L

5.2L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Pickup R3500 1995

List of elements for 5.2L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Pickup R3500 1995:

• (right side of dash panel)
• A/c comp cl rly gnd
• A/c damped press sw
• A14
• A142
• Acc
• Air conditioning system
• Auto shutdown feed
• Auto shutdown relay
• Automatic shut down relay (in pwr dist ctr)
• B/h conn
• Brake sense
• C13
• C20
• Camshaft pos sensor
• Center
• Charge air temp
• Cluster system (fuel gauge)
• Control module
• Cruise control system
• D20
• D21
• Data link receive
• Data link transmit
• Direct battery
• Dist ign sensor (b+)
• Distribution
• Ect sensor
• Egr solenoid
• Egr solenoid (right rear of engine)
• Emrl
• Engine data
• Evap/purge solenoid
• Evap/purge solenoid (left rear of engine)
• F18
• Fuel
• Fuel pump relay (in pwr dist ctr)
• Fuel tank level gauge sending unit (top of fuel tank)
• Fuse 3 ign/acc 40a
• Fuse 4 eng 30a
• Fuse 8 fuel 20a
• Fuse 9 10a
• Fuse block: i/p
• G100 (below horns)
• G125
• G125 (below a/c compressor)
• G14
• G21
• G24
• Generator
• Hot at all times
• Htd oxygen sensor-lt
• Htd oxygen sensor-rt
• Iac motor
• Idle air control motor (on throttle body)
• Ign coil driver
• Ign feed
• Ignition coil (right front of engine)
• Ignition switch
• Inj driver 1
• Inj driver 2
• Inj driver 3
• Inj driver 4
• Inj driver 5
• Inj driver 6
• Inj driver 7
• Inj driver 8
• Injectors
• Instrument
• Instrument cluster system (message center)
• Instrument cluster system (tach)
• K11
• K12
• K13
• K14
• K141
• K17
• K18
• K19
• K20
• K21
• K22
• K24
• K35
• K38
• K39
• K40
• K41
• K44
• K51
• K52
• K54
• K58
• K59
• K60
• Left heated oxygen sensor
• Link connector (right side of dash panel)
• Map sensor
• Mil
• Nca
• Off
• Pnk
• Power
• Power ground
• Powertrain
• Red
• Right heated oxygen sensor
• Run
• Signal ref (b-)
• Start
• Starter rly
• T18
• T41
• T54
• T60
• Tach output
• Tan
• Tan/red
• Throttle position
• Trans ctrl
• Trans od solenoid
• Trans od sw feed
• Trans temp lamp
• Trans temp sensor
• V31
• V32
• V33
• V35
• V36
• V40
• Voltage reg
• Vs ctrl-ign
• Vs ctrl-resume/accel
• Vs ctrl-set/coast
• Vs ctrl-vacuum
• Vs ctrl-vent
• Vss
• Z12

5.2L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Pickup R3500 1995

List of elements for 5.2L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Pickup R3500 1995:

• (behind knee bolster)
• (in distributor)
• (on throttle body)
• (on transmission)
• A/t only
• Anti-lock brakes system (abs controller)
• B/h conn
• C215
• C216
• Camshaft position sensor
• Check engine lamp
• Crankshaft position sensor (right rear of engine)
• Engine coolant temperature sensor (front of engine)
• Fuse 11 10a
• Fuse 12 15a
• Fuse block: i/p
• G206 (i/p left center support)
• Hot in run or start
• Instrument cluster
• Intake air temperature sensor (right front of intake)
• Joint connector c
• Joint connector c (behind knee bolster)
• Maintenance required lamp
• Map sensor (mounted on throttle body)
• Pnk
• Speedo- meter
• Starter relay)
• Starting system (engine
• Stop lamp & vehicle speed control switch
• Throttle position sensor
• Transmission overdrive solenoid (mounted on transmission)
• Transmission overdrive switch
• Transmission range switch
• Transmission temperature sensor (in transmission cooler line)
• Upshift lamp
• Vehicle speed sensor (rear of trans- mission)

5.9L

5.9L Diesel, Engine Performance Wiring Diagrams (1 of 2) for Dodge Pickup R3500 1995

List of elements for 5.9L Diesel, Engine Performance Wiring Diagrams (1 of 2) for Dodge Pickup R3500 1995:

• (front of cylinder head)
• (fuel gauge)
• (left fender side shield)
• (right side of dash panel)
• (tach)
• A/c comp cl rly gnd
• A/c damped press sw
• A/t only
• A14
• A142
• Acc
• Air conditioning system
• Auto shutdown feed
• Auto shutdown relay
• Automatic shut down relay (in pwr dist ctr)
• B/h conn
• Battery
• Brake sense
• C13
• C20
• Center
• Cluster system
• Control module
• Cruise control system
• D20
• D21
• Data link receive
• Data link transmit
• Direct battery
• Dist ign sensor (b+)
• Distribution
• Engine data link connector (right side
• F18
• Fuel heater (near fuel filter)
• Fuel heater relay
• Fuel pump relay (in pwr dist ctr)
• Fuel tank level gauge sending unit (top of fuel tank)
• Fuse 3 ign/acc 40a
• Fuse 4 eng 30a
• Fuse 8 fuel 20a
• Fuse 9 10a
• Fuse block: i/p
• G100 (below horns)
• G125
• G125 (front of cylinder head)
• G14
• G21
• G85
• G86
• Generator
• Generator field
• Heated intake air system (on intake manifold)
• Heated intake air system relay #1 (left fender side shield)
• Heated intake air system relay #2 (left fender side shield)
• Hot at all times
• Htd intake rly #1
• Htd intake rly #2
• Ign feed
• Ignition switch
• Instrument
• Instrument cluster system
• Instrument cluster system (message center)
• Intake air temp
• K20
• K21
• K22
• K24
• K51
• K54
• Knock sensor gnd
• M/t only
• Mil
• Of dash panel)
• Off
• Pnk
• Power
• Power ground
• Powertrain
• Red
• Red/
• Red/ tan
• Run
• S21
• S22
• Signal ref (b-)
• Start
• Starter rly
• T18
• T41
• T54
• T60
• Tach output
• Tan
• Tan/red
• Throttle position
• Trans ctrl
• Trans od solenoid
• Trans od sw feed
• Trans overheat lamp
• Trans temp lamp
• Trans temp sensor
• V31
• V32
• V33
• V35
• V36
• V40
• Vs ctrl-ign
• Vs ctrl-resume/accel
• Vs ctrl-set/coast
• Vs ctrl-vacuum
• Vs ctrl-vent
• Vss
• Wait to start
• Water in fuel sensor
• Z12

5.9L Diesel, Engine Performance Wiring Diagrams (2 of 2) for Dodge Pickup R3500 1995

List of elements for 5.9L Diesel, Engine Performance Wiring Diagrams (2 of 2) for Dodge Pickup R3500 1995:

• (front of cylinder head)
• (in pwr dist ctr)
• (on transmission)
• (top of injection pump)
• A/t
• A/t only
• Anti-lock brakes system (abs controller)
• B/h conn
• C215
• C216
• Check engine lamp
• Cylinder head)
• Engine
• Engine speed sensor (front of engine)
• Fuel shut down relay (left side shield)
• Fuel shutdown solenoid (mounted on injection pump)
• Fuse 11 10a
• Fuse 12 15a
• Fuse block: i/p
• Fuse link 2 40a
• G125
• G206 (i/p left center support)
• Hot at all times
• Hot in run or start
• Instrument cluster
• Intake air temperature sensor (rear of intake)
• Joint connector c (behind knee bolster)
• M/t
• Pnk
• Power distribution center
• Red/
• Relay
• Speedo- meter
• Starter motor)
• Starting system (engine
• Starting system (hot in start)
• Stop lamp & vehicle speed control switch
• Tan
• Throttle position sensor
• Transmission overdrive solenoid (mounted on transmission)
• Transmission overdrive switch
• Transmission range switch
• Transmission temperature sensor (in transmission cooler line)
• Upshift lamp
• Vehicle speed sensor (rear of trans- mission)
• Warnings system
• Water-in fuel sensor (left side of engine)

5.9L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Pickup R3500 1995

List of elements for 5.9L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Pickup R3500 1995:

• (right side of dash panel)
• A/c comp cl rly gnd
• A/c damped press sw
• A14
• A142
• Acc
• Air conditioning system
• Auto shutdown feed
• Auto shutdown relay
• Automatic shut down relay (in pwr dist ctr)
• B/h conn
• Brake sense
• C13
• C20
• Camshaft pos sensor
• Center
• Charge air temp
• Cluster system (fuel gauge)
• Control module
• Cruise control system
• D20
• D21
• Data link receive
• Data link transmit
• Direct battery
• Dist ign sensor (b+)
• Distribution
• Ect sensor
• Egr solenoid
• Egr solenoid (right rear of engine)
• Emrl
• Engine data
• Evap/purge solenoid
• Evap/purge solenoid (left rear of engine)
• F18
• Fuel
• Fuel pump relay (in pwr dist ctr)
• Fuel tank level gauge sending unit (top of fuel tank)
• Fuse 3 ign/acc 40a
• Fuse 4 eng 30a
• Fuse 8 fuel 20a
• Fuse 9 10a
• Fuse block: i/p
• G100 (below horns)
• G125
• G125 (below a/c compressor)
• G14
• G21
• G24
• Generator
• Hot at all times
• Htd oxygen sensor-lt
• Htd oxygen sensor-rt
• Iac motor
• Idle air control motor (on throttle body)
• Ign coil driver
• Ign feed
• Ignition coil (right front of engine)
• Ignition switch
• Inj driver 1
• Inj driver 2
• Inj driver 3
• Inj driver 4
• Inj driver 5
• Inj driver 6
• Inj driver 7
• Inj driver 8
• Injectors
• Instrument
• Instrument cluster system (message center)
• Instrument cluster system (tach)
• K11
• K12
• K13
• K14
• K141
• K17
• K18
• K19
• K20
• K21
• K22
• K24
• K35
• K38
• K39
• K40
• K41
• K44
• K51
• K52
• K54
• K58
• K59
• K60
• Left heated oxygen sensor
• Link connector (right side of dash panel)
• Map sensor
• Mil
• Nca
• Off
• Pnk
• Power
• Power ground
• Powertrain
• Red
• Right heated oxygen sensor
• Run
• Signal ref (b-)
• Start
• Starter rly
• T18
• T41
• T54
• T60
• Tach output
• Tan
• Tan/red
• Throttle position
• Trans ctrl
• Trans od solenoid
• Trans od sw feed
• Trans temp lamp
• Trans temp sensor
• V31
• V32
• V33
• V35
• V36
• V40
• Voltage reg
• Vs ctrl-ign
• Vs ctrl-resume/accel
• Vs ctrl-set/coast
• Vs ctrl-vacuum
• Vs ctrl-vent
• Vss
• Z12

5.9L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Pickup R3500 1995

List of elements for 5.9L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Pickup R3500 1995:

• (behind knee bolster)
• (in distributor)
• (on throttle body)
• (on transmission)
• A/t only
• Anti-lock brakes system (abs controller)
• B/h conn
• C215
• C216
• Camshaft position sensor
• Check engine lamp
• Crankshaft position sensor (right rear of engine)
• Engine coolant temperature sensor (front of engine)
• Fuse 11 10a
• Fuse 12 15a
• Fuse block: i/p
• G206 (i/p left center support)
• Hot in run or start
• Instrument cluster
• Intake air temperature sensor (right front of intake)
• Joint connector c
• Joint connector c (behind knee bolster)
• Maintenance required lamp
• Map sensor (mounted on throttle body)
• Pnk
• Speedo- meter
• Starter relay)
• Starting system (engine
• Stop lamp & vehicle speed control switch
• Throttle position sensor
• Transmission overdrive solenoid (mounted on transmission)
• Transmission overdrive switch
• Transmission range switch
• Transmission temperature sensor (in transmission cooler line)
• Upshift lamp
• Vehicle speed sensor (rear of trans- mission)

8.0L

8.0L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Pickup R3500 1995

List of elements for 8.0L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Pickup R3500 1995:

• #10
• (below a/c compressor)
• (below horns)
• (right side of dash panel)
• (tach)
• A/c comp cl rly gnd
• A/c damped press sw
• A14
• A142
• Acc
• Air conditioning system
• Auto shutdown feed
• Auto shutdown relay
• Automatic shut down relay (in pwr
• B/h conn
• Brake sense
• C13
• C20
• Camshaft pos sensor
• Center
• Charge air temp
• Control module
• Cruise control system
• D20
• D21
• Data link receive
• Data link transmit
• Direct battery
• Dist ctr)
• Dist ign sensor (b+)
• Distribution
• Ect sensor
• Egr solenoid
• Egr solenoid (right rear of engine)
• Emrl
• Engine data
• Engine starter rly
• Evap/purge solenoid
• Evap/purge solenoid (rear of intake)
• F18
• Fuel
• Fuel pump relay (in pwr dist ctr)
• Fuel tank level gauge sending unit (top of fuel tank)
• Fuse 3 ign/acc 40a
• Fuse 4 eng 30a
• Fuse 8 fuel 20a
• Fuse 9 10a
• Fuse block: i/p
• G125
• G125 (below a/c compressor)
• G14
• G21
• G24
• Generator
• Hot at all times
• Htd oxygen sensor-lt
• Htd oxygen sensor-rt
• Iac motor
• Idle air control motor (on throttle body)
• Ign coil (4 pack)
• Ign coil (6 pack)
• Ign feed
• Ignition module
• Ignition switch
• Inj driver 1 & 10
• Inj driver 2 & 7
• Inj driver 3 & 6
• Inj driver 4 & 9
• Inj driver 5 & 8
• Injectors
• Instrument cluster system
• Instrument cluster system (fuel gauge)
• Instrument cluster system (message center)
• K113
• K114
• K115
• K116
• K137
• K138
• K141
• K158
• K18
• K19
• K20
• K21
• K22
• K24
• K35
• K39
• K40
• K41
• K43
• K44
• K51
• K52
• K54
• K59
• K60
• Left heated oxygen sensor
• Link connector (right side
• M/t
• Map sensor
• Mil
• Nca
• Of dash panel)
• Off
• Pnk
• Power
• Power ground
• Powertrain
• Red
• Right heated oxygen sensor
• Run
• Signal ref (b-)
• Start
• T18
• T41
• T54
• T60
• Tach output
• Tan
• Tan/red
• Throttle position
• Trans ctrl
• Trans lamp
• Trans od solenoid
• Trans od sw feed
• Trans temp lamp
• Trans temp sensor
• V31
• V32
• V33
• V35
• V36
• V40
• Voltage reg
• Vs ctrl-ign
• Vs ctrl-resume/accel
• Vs ctrl-set/coast
• Vs ctrl-vacuum
• Vs ctrl-vent
• Vss
• Z12

8.0L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Pickup R3500 1995

List of elements for 8.0L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Pickup R3500 1995:

• (on throttle body)
• (on transmission)
• (right fender side shield)
• A/t only
• B/h
• B/h conn
• C215
• C216
• Camshaft position sensor (on timing cover)
• Check engine lamp
• Conn
• Control
• Crankshaft position sensor (right side of engine, near motor mount)
• Engine coolant temperature sensor (front of engine)
• F18
• Fuse 11 10a
• Fuse 12 15a
• Fuse block: i/p
• G125 (below a/c compressor)
• G206 (i/p left center support)
• Hot in run or start
• Ignition coil 4-pack (rear of cylinder head)
• Ignition coil 6-pack (rear of cylinder head)
• Ignition module
• Instrument cluster
• Intake air temperature sensor (on intake manifold)
• Joint connector c (behind knee bolster)
• K137
• K138
• K17
• K32
• Maintenance required lamp
• Map sensor (on throttle body)
• Pnk
• Red/
• Speed
• Speedo- meter
• Starter relay)
• Starting system (engine
• Stop lamp & vehicle
• Switch
• Tan
• Throttle position sensor
• Transmission overdrive solenoid (mounted on transmission)
• Transmission overdrive switch
• Transmission range switch
• Transmission temperature sensor (in transmission cooler line)
• Upshift lamp
• Vehicle speed sensor (left side of trans- mission)
• Z12