ENGINE PERFORMANCE – Ford Ranger 1995 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

2.3L

2.3L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger 1995

List of elements for 2.3L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger 1995:

• 4x4 indicator
• A/c clutch
• Air conditioning system
• C209
• C216
• Coast clutch
• Crank pos (+)
• Crank pos (-)
• Crankshaft position (ckp) sensor (lower right front of engine)
• Data link connector (dlc) (bottom of i/p, right of steering column)
• Dlc
• Dlc bus (+)
• Dlc bus (-)
• Ect sens
• Engine compartment fuse/relay box (left rear of engine compt.)
• Evap
• Evr
• Fuel pmp rly
• Fuse 15a
• Fuse 25a
• G104 (top center of left fender apron)
• G108 (left side of radiator support)
• G123 (right side of safety wall
• G123 (right side of safety wall)
• Ground
• Ho2s #2
• Hot at all times
• Hot in run or start
• I/p fuse panel (left side of i/p)
• Iat sens
• Ignition coil #1
• Ignition coil #2
• Instrument cluster
• Instrument cluster system
• Maf sens
• Malfunction indicator lamp (mil)
• Mil
• Noise capacitor (near ignition coil)
• Octane plug
• Pcm power diode
• Pcm power fuse 13 30a
• Pcm power relay
• Powertrain control module (pcm) (right rear of engine compt.)
• Primary coil (top right side of engine)
• Psp
• Red
• Secondary coil (top right front of engine)
• Shift sol 1
• Shift sol 2
• Tach
• Tcs
• Trans temp

2.3L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger 1995

List of elements for 2.3L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger 1995:

• A/t
• Air conditioning system
• Clutch pedal position (cpp) switch (clutch pedal support)
• Clutch pedal position (cpp) switch jumper (left side of i/p)
• Differential pressure feedback egr (dpfe) sensor (right rear of engine)
• Engine compartment fuse/relay box (left rear of engine compt.)
• Engine coolant temperature (ect) sensor (top right front of engine)
• Evaporative emissions (evap) canister purge valve (left front of engine compt.)
• Evaporative emissions (evap) purge flow sensor (left front of engine compt.)
• Fuel pump relay
• Fuel sys/ anti-theft fuse 12 20a
• G108 (left side of radiator support)
• Horn/pcm memory power fuse 4 20a
• Hot at all times
• Intake air temperature (iat) sensor (air intake assembly)
• M/t
• Nca
• Octane adjust shorting bar (near pcm)
• Power distribution system
• Power steering pressure (psp) switch (left front of engine compt.)
• Red
• Throttle position (tp) sensor (throttle body)

2.3L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger 1995

List of elements for 2.3L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger 1995:

• (below glove box) inertia fuel shut-off (ifs)
• C214
• Egr vacuum regulator (evr) solenoid (right side of engine)
• Engine compartment fuse/relay box (left rear of engine compt.)
• Fuel injectors
• Fuel pump module (top of fuel tank)
• Fuse 15a
• G200 (behind left cowl panel)
• Ho2s fuse 20 15a
• Hot in run
• I/p fuse panel (left side of i/p)
• Instrument cluster
• Instrument cluster system
• Red
• Tan
• Transmission control indicator lamp
• Transmission control switch (tcs)

2.3L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger 1995

List of elements for 2.3L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger 1995:

• (top of transaxle) transmission range sensor
• 4r44e/4r55e transmission
• A/c wot
• Air conditioning system
• Brake on/off
• Brake on/off switch
• Cam pos sens
• Camshaft position sensor (behind oil pump pulley)
• Coast clutch solenoid
• Cruise control system, instrument cluster system, body computer system
• Dpfe sens
• Electronic pressure control solenoid
• Epc sol
• Evap
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel pmp rly
• Fuse 15a
• G108 (left side of radiator support)
• G123 (right side of safety wall)
• Ground
• Heated oxygen sensor #1 (lower right side of engine)
• Heated oxygen sensor #2 (lower right side of engine)
• Heater ctrl
• Ho2s #1
• Ho2s #2
• Hot at all times
• I/p fuse panel (left side of i/p)
• Iac sol
• Idle air control (iac) valve (top right rear of engine)
• Ignition coil #2
• Ignition coil #4
• Maf sens
• Mass air flow (maf) sensor (air cleaner assembly)
• Nca
• Power
• Powertrain control module (pcm) (right rear of engine compt.)
• Red
• Ref volt
• Shift sol 3
• Shift solenoids
• Sig rtn
• Tan
• Tcc
• Tcil
• Torque converter clutch solenoid
• Tp sens
• Tr sens
• Transmission fluid temperature sensor
• Tss (+)
• Turbine shaft speed sensor (tss)
• Vehicle speed sensor (vss) (left rear of trans./transfer case)
• Vss in

3.0L

3.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger 1995

List of elements for 3.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger 1995:

• 4x4 indicator
• A/c clutch
• Air conditioning system
• C209
• C216
• Coast clutch
• Crank pos (+)
• Crank pos (-)
• Crankshaft position (ckp) sensor (lower front of engine)
• Data link connector (dlc) (bottom of i/p, right of steering column)
• Dlc
• Dlc bus (+)
• Dlc bus (-)
• Ect sens
• Engine compartment fuse/relay box (left rear of engine compt.)
• Evap
• Evr
• Fuel pmp rly
• Fuse 15a
• Fuse 25a
• G104 (top center of left fender apron)
• G108 (left side of radiator support)
• G123 (right side of safety wall
• G123 (right side of safety wall)
• Ground
• Ho2s #3
• Hot at all times
• Hot in run or start
• I/p fuse panel left side of i/p)
• Iat sens
• Ignition coil
• Ignition coil (top right rear of engine)
• Instrument cluster
• Instrument cluster system
• Maf sens
• Malfunction indicator lamp (mil)
• Mil
• Noise capacitor (near ignition coil)
• Octane plug
• Pcm power diode
• Pcm power fuse 13 30a
• Pcm power relay
• Powertrain control module (pcm) (right rear of engine compt.)
• Primary
• Red
• Secondary
• Shift sol 1
• Shift sol 2
• Tach
• Tcs
• To spark plugs
• Trans temp

3.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger 1995

List of elements for 3.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger 1995:

• 3.0l
• 4.0l
• A/t
• Air conditioning system
• Clutch pedal position (cpp) switch (clutch pedal support)
• Clutch pedal position (cpp) switch jumper (left side of i/p)
• Differential pressure feedback egr (dpfe) sensor (left side of engine)
• Engine compartment fuse/relay box (left rear of engine compt.)
• Engine coolant temperature (ect) sensor (top left front of engine)
• Evaporative emissions (evap) canister purge valve (left front of engine compt.)
• Evaporative emissions (evap) purge flow sensor (left front of engine compt.)
• Fuel pump relay
• Fuel sys/ anti-theft fuse 12 20a
• G108 (left side of radiator support)
• Horn/pcm memory power fuse 4 20a
• Hot at all times
• Intake air temperature (iat) sensor (air intake assembly)
• M/t
• Nca
• Octane adjust shorting bar (near pcm)
• Power distribution system
• Red
• Throttle position (tp) sensor (throttle body)

3.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger 1995

List of elements for 3.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger 1995:

• (4.0l) (3.0l)
• (below glove box) inertia fuel shut-off (ifs)
• C214
• Egr vacuum regulator (evr) solenoid (left rear of engine) (right side of engine)
• Engine compartment fuse/relay box (left rear of engine compt.)
• Fuel injectors
• Fuel pump module (top of fuel tank)
• Fuse 15a
• G200 (behind left cowl panel)
• Ho2s fuse 20 15a
• Hot in run
• I/p fuse panel (left side of i/p)
• Instrument cluster
• Instrument cluster system
• Red
• Tan
• Transmission control indicator lamp
• Transmission control switch (tcs)

3.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger 1995

List of elements for 3.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger 1995:

• (left side of radiator support)
• (top of transaxle) transmission range sensor
• 4r44e/4r55e transmission
• A/c wot
• Air conditioning system
• Brake on/off
• Brake on/off switch
• Cam pos sens
• Camshaft position sensor (top rear of engine)
• Coast clutch solenoid
• Cruise control system, instrument cluster system, body computer system
• Dpfe sens
• Electronic pressure control solenoid
• Epc sol
• Evap
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel pmp rly
• Fuse 15a
• G108
• G108 (left side of radiator support)
• G123 (right side of safety wall)
• Ground
• Heated oxygen sensor #1 (right rear of engine)
• Heated oxygen sensor #2 (lower left rear of engine)
• Heated oxygen sensor #3 (near right side of transmission)
• Heater ctrl
• Ho2s #1
• Ho2s #2
• Ho2s #3
• Hot at all times
• I/p fuse panel (left side of i/p)
• Iac sol
• Idle air control (iac) valve (top left rear of engine)
• Ignition coil #2
• Maf sens
• Mass air flow (maf) sensor (air cleaner assembly)
• Nca
• Power
• Powertrain control module (pcm) (right rear of engine compt.)
• Red
• Ref volt
• Shift sol 3
• Shift solenoids
• Sig rtn
• Tan
• Tcc
• Tcil
• Torque converter clutch solenoid
• Tp sens
• Tr sens
• Transmission fluid temperature sensor
• Tss (+)
• Turbine shaft speed sensor (tss)
• Vehicle speed sensor (vss) (left rear of trans./transfer case)
• Vss in

4.0L

4.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger 1995

List of elements for 4.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Ranger 1995:

• 4x4 indicator
• A/c clutch
• Air conditioning system
• C209
• C216
• Coast clutch
• Crank pos (+)
• Crank pos (-)
• Crankshaft position (ckp) sensor (lower front of engine)
• Data link connector (dlc) (bottom of i/p, right of steering column)
• Dlc
• Dlc bus (+)
• Dlc bus (-)
• Ect sens
• Engine compartment fuse/relay box (left rear of engine compt.)
• Evap
• Evr
• Fuel pmp rly
• Fuse 15a
• Fuse 25a
• G104 (top center of left fender apron)
• G108 (left side of radiator support)
• G123 (right side of safety wall
• G123 (right side of safety wall)
• Ground
• Ho2s #3
• Hot at all times
• Hot in run or start
• I/p fuse panel left side of i/p)
• Iat sens
• Ignition coil
• Ignition coil (top right rear of engine)
• Instrument cluster
• Instrument cluster system
• Maf sens
• Malfunction indicator lamp (mil)
• Mil
• Noise capacitor (near ignition coil)
• Octane plug
• Pcm power diode
• Pcm power fuse 13 30a
• Pcm power relay
• Powertrain control module (pcm) (right rear of engine compt.)
• Primary
• Red
• Secondary
• Shift sol 1
• Shift sol 2
• Tach
• Tcs
• To spark plugs
• Trans temp

4.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger 1995

List of elements for 4.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Ranger 1995:

• 3.0l
• 4.0l
• A/t
• Air conditioning system
• Clutch pedal position (cpp) switch (clutch pedal support)
• Clutch pedal position (cpp) switch jumper (left side of i/p)
• Differential pressure feedback egr (dpfe) sensor (left side of engine)
• Engine compartment fuse/relay box (left rear of engine compt.)
• Engine coolant temperature (ect) sensor (top left front of engine)
• Evaporative emissions (evap) canister purge valve (left front of engine compt.)
• Evaporative emissions (evap) purge flow sensor (left front of engine compt.)
• Fuel pump relay
• Fuel sys/ anti-theft fuse 12 20a
• G108 (left side of radiator support)
• Horn/pcm memory power fuse 4 20a
• Hot at all times
• Intake air temperature (iat) sensor (air intake assembly)
• M/t
• Nca
• Octane adjust shorting bar (near pcm)
• Power distribution system
• Red
• Throttle position (tp) sensor (throttle body)

4.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger 1995

List of elements for 4.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Ranger 1995:

• (4.0l) (3.0l)
• (below glove box) inertia fuel shut-off (ifs)
• C214
• Egr vacuum regulator (evr) solenoid (left rear of engine) (right side of engine)
• Engine compartment fuse/relay box (left rear of engine compt.)
• Fuel injectors
• Fuel pump module (top of fuel tank)
• Fuse 15a
• G200 (behind left cowl panel)
• Ho2s fuse 20 15a
• Hot in run
• I/p fuse panel (left side of i/p)
• Instrument cluster
• Instrument cluster system
• Red
• Tan
• Transmission control indicator lamp
• Transmission control switch (tcs)

4.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger 1995

List of elements for 4.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Ranger 1995:

• (left side of radiator support)
• (top of transaxle) transmission range sensor
• 4r44e/4r55e transmission
• A/c wot
• Air conditioning system
• Brake on/off
• Brake on/off switch
• Cam pos sens
• Camshaft position sensor (top rear of engine)
• Coast clutch solenoid
• Cruise control system, instrument cluster system, body computer system
• Dpfe sens
• Electronic pressure control solenoid
• Epc sol
• Evap
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel pmp rly
• Fuse 15a
• G108
• G108 (left side of radiator support)
• G123 (right side of safety wall)
• Ground
• Heated oxygen sensor #1 (right rear of engine)
• Heated oxygen sensor #2 (lower left rear of engine)
• Heated oxygen sensor #3 (near right side of transmission)
• Heater ctrl
• Ho2s #1
• Ho2s #2
• Ho2s #3
• Hot at all times
• I/p fuse panel (left side of i/p)
• Iac sol
• Idle air control (iac) valve (top left rear of engine)
• Ignition coil #2
• Maf sens
• Mass air flow (maf) sensor (air cleaner assembly)
• Nca
• Power
• Powertrain control module (pcm) (right rear of engine compt.)
• Red
• Ref volt
• Shift sol 3
• Shift solenoids
• Sig rtn
• Tan
• Tcc
• Tcil
• Torque converter clutch solenoid
• Tp sens
• Tr sens
• Transmission fluid temperature sensor
• Tss (+)
• Turbine shaft speed sensor (tss)
• Vehicle speed sensor (vss) (left rear of trans./transfer case)
• Vss in