ENGINE PERFORMANCE – Hyundai Santa Fe 2001 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

2.4L

2.4L, Engine Performance Wiring Diagrams, A/T (1 of 4) for Hyundai Santa Fe 2001

List of elements for 2.4L, Engine Performance Wiring Diagrams, A/T (1 of 4) for Hyundai Santa Fe 2001:

• (ecu)
• A/c rel
• A/c sig in
• A/c system
• Air temp sens
• Atm relay
• Battery
• C21-1
• C21-2
• Ccv
• Check engine ind
• Ckp sens
• Close
• Cmp sens
• Cooling fans system
• Cooling sig in
• E/r-d
• E/r-f
• E/r-g
• E/r-h
• Ect sens
• Ecu (b+) fuse 15a
• Ecu 2 fuse 20a
• Ecu 3 fuse (diagram 2 of 4)
• Egr sol
• Egr solenoid valve (behind right strut tower)
• Eng ctrl rly
• Eng rly on
• Engine compartment junction block (left side of eng comt)
• Engine control relay
• Fan rly (hi)
• Fan rly (lo)
• Flash source
• Ft o2 htr
• Fuel cut solenoid
• Fuel injectors
• Fuel pmp ctrl
• Fuel pump check connector
• Fuel pump relay
• Fuel sender & fuel pump motor (in fuel tank)
• Fuse 19 10a
• Fusible link 40a
• G118 (right front frame rail)
• G302 (below center console)
• G402 (left rear wheelwell)
• Ground
• Hot at all times
• Hot in on or start
• I/p-m
• Idle speed control actuator (right rear of eng)
• Ign coil 1, 4
• Ign coil 2, 3
• Ign det sig
• Ignition coil 1 (top rear of eng)
• Ignition coil 2 (top front of eng)
• Inj 1
• Inj 2
• Inj 3
• Inj 4
• Instrument cluster
• Instrument cluster system (tach)
• Joint con- nector m04 (behind left side of dash)
• Joint connector m05 (behind left side of dash)
• M15-1
• Maf sen
• Mem pwr
• Mil ctrl
• Nca
• Open
• P/n input
• P/s sw
• Passenger compartment junction block (left side of dash)
• Pcm (below center of dash)
• Pnk
• Power steering switch (left front of eng)
• Purge control solenoid valve (top front of eng)
• Purge sol
• Red
• Rr o2 htr
• Sens ground
• Sens pwr
• Start sig
• Starting/ charging system
• To spark plugs

2.4L, Engine Performance Wiring Diagrams, A/T (2 of 4) for Hyundai Santa Fe 2001

List of elements for 2.4L, Engine Performance Wiring Diagrams, A/T (2 of 4) for Hyundai Santa Fe 2001:

• Atm fuse 20a
• Canister close valve (near canister)
• E/r-f
• E/r-g
• E/r-h
• Ecu 1 fuse 20a
• Ecu 3 fuse 10a
• Engine compartment junction block (left side of eng comt)
• Engine coolant temperature sensor & sender (rear of eng)
• From engine control relay a (diagram 1 of 4)
• Front oxygen sensor (on exhaust manifold)
• G302 (below center console)
• Hot at all times
• Ignition failure sensor (top rear of eng)
• Instrument cluster system
• Joint con- nector c33 (left front of eng compt)
• Joint connector c34 (under dash, near gas pedal)
• Manifold absolute pressure sensor (right of intake manifold)
• Nca
• Pnk
• Rear oxygen sensor (on front of front exhaust pipe)
• Red
• Sender
• Sensor

2.4L, Engine Performance Wiring Diagrams, A/T (3 of 4) for Hyundai Santa Fe 2001

List of elements for 2.4L, Engine Performance Wiring Diagrams, A/T (3 of 4) for Hyundai Santa Fe 2001:

• (left side of dash) data link connector
• (left side of dash) multipurpose check connector
• (on right front of eng compt) cruise control module
• (top of transaxle) vehicle speed sensor
• (under dash, front of center support bracket) joint connector c35
• Camshaft position sensor (left rear of eng)
• Crankshaft position sensor (left front of eng)
• E/r-d
• Engine compartment junction block (left side of eng comt) e/r-g
• Etacs control module
• Fuel tank pressure sensor (under rear of vehicle, near fuel tank)
• Fuse 10a
• G302 (below center console)
• G302 (below center dash)
• Hot in on or start
• Hot in on or start passenger compartment junction block (left side of dash)
• I/p-b
• I/p-l
• I/p-m
• Instrument cluster system
• Joint con- nector c33 (left front of eng compt)
• Joint connector mo6 (behind left side of dash)
• Knock sensor (rear of eng)
• M13-3
• Mass air- flow sensor (on air intake duct)
• Nca
• Pnk
• Red
• Throttle position sensor (on throttle body assembly)

2.4L, Engine Performance Wiring Diagrams, A/T (4 of 4) for Hyundai Santa Fe 2001

List of elements for 2.4L, Engine Performance Wiring Diagrams, A/T (4 of 4) for Hyundai Santa Fe 2001:

• (below center console) g302
• (left kick panel) g200
• 1 input
• 2 input
• 2nd
• 3 input
• 4 input
• A/c on sig
• A/c system
• A/t pulse generator a (on top of transaxle)
• A/t pulse generator b (on top of transaxle)
• Atm control relay (at base of crash pad center support bracket)
• Atm solenoid assembly (in transaxle valve body)
• Auto cruise
• Battery
• C21-3
• C21-4
• Cruise control system
• D input
• Dcc
• Down shift
• Exterior lights system (stop lamp switch)
• Exterior lihgts system (back-up lamp)
• Flash source
• Ft o2 sens
• Ftp sens
• G302 (below center console)
• Ground
• Ign timing adj
• Instrument cluster
• Joint connector c35
• Joint connector c35 (under dash, front of center bracket)
• K-line diag
• Ks sig
• Map sens
• N input
• Normal
• O/t
• Oil temp sensor
• On/start in
• P input
• Pcm (below center of dash)
• Pnk
• Pulse gen a
• Pulse gen b
• R input
• Red
• Rr o2 sens
• Select
• Select sw
• Sport mode switch
• Starting/ charging system
• Stop lamp sw
• Tps sig
• Transaxle range switch (on top of transaxle)
• Up shift
• Vss input

2.4L, Engine Performance Wiring Diagrams, M/T (1 of 3) for Hyundai Santa Fe 2001

List of elements for 2.4L, Engine Performance Wiring Diagrams, M/T (1 of 3) for Hyundai Santa Fe 2001:

• (ecu)
• A/c on sig
• A/c rel
• A/c sig in
• A/c system
• Battery
• C21-1
• Check engine ind
• Close
• Cooling fans system
• Cooling sig in
• E/r-d
• E/r-f
• E/r-g
• E/r-h
• Ecm (below center of dash)
• Ecu (b+) fuse 15a
• Ecu 2 fuse 20a
• Ecu 3 fuse (diagram 2 of 3)
• Egr sol
• Egr solenoid valve (behind right strut tower)
• Eng ctrl rly
• Eng rly on
• Engine compartment junction block (left side of eng comt)
• Engine control relay
• Fan rly (hi)
• Fan rly (lo)
• Fuel cut solenoid
• Fuel injectors
• Fuel pmp ctrl
• Fuel pump check connector
• Fuel pump relay
• Fuel sender & fuel pump motor (in fuel tank)
• Fuse 19 10a
• Fusible link 40a
• G11
• G118 (right front frame rail)
• G302 (below center console)
• G402 (left rear wheelwell)
• Ground
• Hot at all times
• Hot in on or start
• I/p-m
• Idle speed control actuator (right rear of eng)
• Ign coil 1, 4
• Ign coil 2, 3
• Ignition coil 1 (top rear of eng)
• Ignition coil 2 (top front of eng)
• Inj 1
• Inj 2
• Inj 3
• Inj 4
• Instrument cluster
• Joint con- nector m04 (behind left side of dash)
• Joint connector m05 (behind left side of dash)
• M15-1
• Mil ctrl
• Nca
• Open
• P/s sw
• Passenger compartment junction block (left side of dash)
• Pnk
• Power steering switch (left front of eng)
• Purge control solenoid valve (top front of eng)
• Purge sol
• Red
• To spark plugs

2.4L, Engine Performance Wiring Diagrams, M/T (2 of 3) for Hyundai Santa Fe 2001

List of elements for 2.4L, Engine Performance Wiring Diagrams, M/T (2 of 3) for Hyundai Santa Fe 2001:

• Canister close valve (near canister)
• E/r-g
• E/r-h
• Ecu 1 fuse 20a
• Ecu 3 fuse 10a
• Engine compartment junction block (left side of eng comt)
• Engine coolant temperature sensor & sender (rear of eng)
• From engine control relay a (diagram 1 of 3)
• Front oxygen sensor (on exhaust manifold)
• Fuel tank pressure sensor (under rear of vehicle, near fuel tank)
• G302 (below center console)
• Ignition failure sensor (top rear of eng)
• Instrument cluster system
• Joint con- nector c33 (left front of eng compt)
• Joint connector c34 (under dash, near gas pedal)
• Manifold absolute pressure sensor (right of intake manifold)
• Nca
• Pnk
• Rear oxygen sensor (on front of front exhaust pipe)
• Red
• Sender
• Sensor

2.4L, Engine Performance Wiring Diagrams, M/T (3 of 3) for Hyundai Santa Fe 2001

List of elements for 2.4L, Engine Performance Wiring Diagrams, M/T (3 of 3) for Hyundai Santa Fe 2001:

• (left side of dash) data link connector
• (left side of dash) multipurpose check connector
• (on right front of eng compt) cruise control module
• (top of transaxle) vehicle speed sensor
• Air temp sens
• Ats sig
• C22-3
• C22-4
• Camshaft position sensor (left rear of eng)
• Ccv ctrl
• Ckp sens
• Cmp sens
• Crankshaft position sensor (left front of eng)
• E/r-d
• Ect sens
• Engine compartment junction block (left side of eng comt) e/r-g
• Etacs control module
• Flash source
• Ft o2 htr
• Ft o2 sens
• Ftp sens
• Fuse 10a
• G302 (below center console)
• G302 (below center dash)
• Ground
• Hot in on or start
• Hot in on or start passenger compartment junction block (left side of dash)
• I/p-b
• I/p-l
• I/p-m
• Ign det sig
• Ign timing adj
• Instrument cluster system
• Instrument cluster system (tachometer)
• Joint con- nector c33 (left front of eng compt)
• Joint connector mo6 (behind left side of dash)
• K-line diag
• Knock sensor (rear of eng)
• Ks sig
• M13-3
• Map sen
• Mass air- flow sensor (on air intake duct)
• Mem pwr
• Nca
• On/start in
• Pcm (below center of dash)
• Pnk
• Red
• Rr o2 htr
• Rr o2 sens
• Sens ground
• Sens pwr
• Start sig
• Starting/ charging system
• Throttle position sensor (on throttle body assembly)
• Tps sig
• Vss input

2.7L

2.7L, Engine Performance Wiring Diagrams (1 of 4) for Hyundai Santa Fe 2001

List of elements for 2.7L, Engine Performance Wiring Diagrams (1 of 4) for Hyundai Santa Fe 2001:

• (below center console)
• (ecu)
• (pins 11-16)
• (pins 2-6)
• (pins 2-7)
• (pins 27-28)
• (pins 39-41)
• (pins 43-45)
• (pins 48-52)
• (pins 8-12)
• 02s heating
• Air temp in
• Air temperature sensor (righ side of intake manifold)
• Ats grd
• Battery
• C23-1
• C23-2
• C23-3
• Ckp sens grd
• Ckp signal
• Closing
• E/r-d
• E/r-f
• E/r-g
• Ecm relay
• Ect input
• Ect sens grd
• Ecu (b+) fuse 15a
• Ecu 3 fuse (diagram 2 of 4)
• Engine control module (ecm) (behind lower center of dash)
• Engine control relay
• Engine coolant temperature sensor & sender (rear of engine)
• Fuel cut solenoid
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel injectors
• Fuel pump check connector
• Fuel pump relay
• Fuel sender & fuel pump motor (in fuel tank)
• Fuse 20a
• Fusible link 40a
• G302
• G402 (left rear wheelwell)
• Ground
• Hot at all times
• Hot at all times engine compartment junction block (left side of eng comt)
• Hot in on or start passenger compartment junction block (left side of dash)
• I/p-l
• Ignition
• Instrument cluster system
• Joint con- nector m04 (behind left side of dash)
• K-line
• Ks sig input
• Maf sens grd
• Maf signal
• Mem pwr
• Nca
• O2s
• O2s ground
• O2s heating
• Opening
• Pcsv cntrl
• Pnk
• Purge control solenoid valve (righ side of intake manifold)
• Pwr strg sw
• Red
• Sens ground
• Tp sens

2.7L, Engine Performance Wiring Diagrams (2 of 4) for Hyundai Santa Fe 2001

List of elements for 2.7L, Engine Performance Wiring Diagrams (2 of 4) for Hyundai Santa Fe 2001:

• (left side of dash) data link connector
• (left side of dash) multipurpose check connector
• E/r-e
• E/r-g
• E/r-h
• Ecu 1 fuse 20a
• Ecu 2 fuse 20a
• Ecu 3 fuse 10a
• Engine compartment junction block (left side of eng comt)
• From fuse a control relay (diagram 1 of 4)
• Front oxygen sensor (bank 1 sensor 1) (bottom of right exhaust manifold)
• Front oxygen sensor (bank 2 sensor 1) (near top of left exhaust manifold)
• Knock sensor 1 (left rear of eng)
• Knock sensor 2 (left rear of eng0
• Nca
• Pnk
• Power steering switch (top of power steering assembly)
• Rear oxygen sensor (bank 1 sensor 2) (on bottom of right exhaust manifold downpipe)
• Rear oxygen sensor (bank 2 sensor 2) (on front exhaust pipe, upstream of catalytic converter)
• Red

2.7L, Engine Performance Wiring Diagrams (3 of 4) for Hyundai Santa Fe 2001

List of elements for 2.7L, Engine Performance Wiring Diagrams (3 of 4) for Hyundai Santa Fe 2001:

• (on right front of eng compt) cruise control module
• (top of transaxle) vehicle speed sensor
• Camshaft position sensor (left rear of eng)
• Canister close valve (near canister)
• Crankshaft position sensor (on rear of engine, above starter)
• E/r-d
• Engine compartment junction block (left side of eng comt) e/r-g
• Etacs control module
• Fuse 10a
• G302 (below center dash)
• Hot in on or start
• I/p-b
• I/p-l
• I/p-m
• Idle speed control actuator (rear of eng)
• Instrument cluster system
• Joint con- nector c33 (left front of eng compt)
• Joint connector mo6 (behind left side of dash)
• M13-3
• Mass air- flow sensor (on intake air duct)
• Nca
• Passenger compartment junction block (left side of dash)
• Pnk
• Red
• Throttle position sensor (on throttle body assembly)

2.7L, Engine Performance Wiring Diagrams (4 of 4) for Hyundai Santa Fe 2001

List of elements for 2.7L, Engine Performance Wiring Diagrams (4 of 4) for Hyundai Santa Fe 2001:

• (behind lower center of dash) transmission control module
• (below brake master cylinder) abs control module
• A/c on input
• A/c press
• A/c rly ctrl
• A/c sig input
• Air conditioning system
• C23-4
• C23-5
• Ccv
• Chck eng ind
• Check engine ind
• Cmp sens grd
• Cmp sig in
• Cod fan rly
• Com ntwk hi
• Com ntwk lo
• Condenser
• Cooling fans system
• Eng spd sig
• Engine control module (ecm) (behind lower center of dash)
• Ftp sens
• Fuel pmp rly
• Fuel tank pressure sensor (under rear of vehicle, near fuel tank)
• G302 (below center console)
• Ground
• Ignition coil (top rear of engine)
• Ing coil ctrl
• Instrument cluster
• M15-1
• Nca
• Pnk
• Rad fan rly
• Red
• Right front wheel sensor (without abs)
• Sens ground
• Sens pwr
• Spark plugs
• Tachometer
• Vss
• Wheel spd in
• Whl spd in