ENGINE PERFORMANCE – Pontiac G5 2007 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

2.2L VIN F

2.2L VIN F, Engine Performance Wiring Diagram (1 of 4) for Pontiac G5 2007

List of elements for 2.2L VIN F, Engine Performance Wiring Diagram (1 of 4) for Pontiac G5 2007:

• (left side of engine compt, under coolant reservoir) g101
• 5v ref 1
• 5v ref 2
• A/c com rly ctrl
• A/c ref sens sig
• Acc
• Acc vol
• Acc volt
• Air conditioning system
• Air pump rly ctrl
• App sens 1 sig
• App sens 2 sig
• Batt pos vol
• Body control module (bcm) (under center dash, on right side of center console)
• Clutch pedal position (cpp) switch (m/t) (under left side of dash, at top of clutch pedal)
• Computer data lines system
• Cooling fan rly ctrl
• Cooling fans system
• Cpp sw sig
• Ecm/ trans fuse 43 15a
• Engine control module (ecm) (left side of engine compt, in front of underhood fuse block)
• Evaporative emission (evap) canister vent solenoid (under rear of vehicle, behind fuel tank attached to evap canister)
• Exterior lights system
• Fuel level sens sig
• Fuel pmp rly ctrl
• Fuel tank pressure (ftp) sensor (top of fuel tank)
• Ground
• Hi spd cool fan rly
• Hot at all times
• Iat sens sig
• Ign 1 voltage
• Ignition 1 vol
• Ignition switch
• Logic
• Low ref
• Maf sens sig
• Mil ctrl
• Off
• Pnp/clutch sw sig
• Powertrain rly ctrl
• Press sens sig
• Relay coil ctrl c1
• Rly coil ctrl
• Run
• Run/ crank relay
• S206 (a/t)
• Serial bus +
• Serial bus -
• Start
• Starting/charging system
• Stop lamp sw sig
• Tan
• Tan a
• Tcc brake sw
• Transmissions system
• Underhood fuse block (in engine compt, next to left strut tower)
• Vehicle speed sensor (vss) (m/t) (top of manual transmission)
• Vent sol ctrl
• Vss high sig
• Vss low sig

2.2L VIN F, Engine Performance Wiring Diagram (2 of 4) for Pontiac G5 2007

List of elements for 2.2L VIN F, Engine Performance Wiring Diagram (2 of 4) for Pontiac G5 2007:

• (front of engine compt, near cooling fans) g111
• (lower left front of transmission case) g105
• (near accelerator pedal bracket) accelerator pedal position (app) sensor
• Air pmp fuse 40a
• Air pmp relay
• Air sol fuse (w/ nu3) 15a
• Air sol relay
• Cnstr vent fuse 64 10a
• Computer data lines system
• Data gmlan
• Ecm fuse 41 15a
• Emisn fuse 33 10a
• Evaporative emission (evap) canister purge solenoid (top, rear of engine)
• Hot at all times
• Ign
• Inj fuse 45 10a
• Instrument panel cluster (ipc)
• Logic
• Malfunc- tion indicator lamp
• Nca
• Pnk
• Pwr/trn relay
• Secondary air injection (air) pump (lower left side of engine, near oil pan)
• Secondary air injection reaction (air) solenoid (top, right side of engine, near exhaust manifold)
• Tan
• Underhood fuse block (in engine compt, next to left strut tower)

2.2L VIN F, Engine Performance Wiring Diagram (3 of 4) for Pontiac G5 2007

List of elements for 2.2L VIN F, Engine Performance Wiring Diagram (3 of 4) for Pontiac G5 2007:

• (center of rear shelf, near speaker) g402
• (lower left front of transmission case) g105
• (top, left side of engine, under fuel rail assembly) fuel injectors
• (under left side of dash, at top of brake pedal)
• Body control module (bcm) (under center dash, on right side of center console)
• Ecm/ tcm fuse 25 10a
• Fuel level sensor
• Fuel pump & sender assembly (inside fuel tank)
• Fuel pump fuse 15a
• Fuel pump motor
• Fuel pump relay
• G101 (left side of engine compt, under coolant reservoir)
• G107 (upper front, right side of engine, near exhaust)
• Gnd
• Hot at all times
• Hot in acc or run
• Hvac/ ip ign fuse 16 10a
• Iat
• Ic 1 ctrl
• Ic 2 ctrl
• Ign 1 vol
• Ignition coil/ module 1 (top of engine, under cover at cylinder 1)
• Ignition coil/ module 2 (top of engine, under cover at cylinder 2)
• Low ref
• Maf
• Manifold absolute pressure (map) sensor (top front of engine at cylinder 3 intake port runner)
• Mass air flow (maf)/inlet air temperature (iat) sensor (on intake, after air cleaner)
• Pnk
• Power distribution
• S104
• S106
• S107
• Stop lamp switch (under left side of dash, at top of brake pedal)
• Stop lamp/
• Stop lp fuse 9 10a
• System
• System lights exterior
• Tan
• Tcc switch
• Underhood fuse block (in engine compt, next to left strut tower)

2.2L VIN F, Engine Performance Wiring Diagram (4 of 4) for Pontiac G5 2007

List of elements for 2.2L VIN F, Engine Performance Wiring Diagram (4 of 4) for Pontiac G5 2007:

• (rear of engine compt, in exhaust manifold) heated oxygen sensor (ho2s) 1
• (rear of engine compt, in exhaust, after catalytic converter) heated oxygen sensor (ho2s) 2
• (top of intake manifold) throttle actuator control (tac) module
• 5v ref
• 5v ref 1
• 5v ref 2
• A/c refrigerant pressure sensor (right front of engine compt, on a/c line, near compressor)
• Air sol ctrl
• Camshaft position (cmp) sensor intake
• Ckp sens sig
• Cmp sens sig
• Crankshaft position (ckp) sensor (above starter motor)
• Ect sens sig
• Engine control module (ecm) (left side of engine compt, in front of underhood fuse block)
• Engine coolant temperature (ect) sensor (rear of engine, near exhaust manifold)
• Engine oil pressure switch (left side of engine, above starter)
• Fuel inj 1 ctrl
• Fuel inj 2 ctrl
• Fuel inj 3 ctrl
• Fuel inj 4 ctrl
• G107 (upper front, right side of engine, near exhaust)
• Gen field duty
• Gen trn on sig
• Gnd
• Hi sig sens 1
• Hi sig sens 2
• Ic 1 ctrl
• Ic 2 ctrl
• Ic 3 ctrl
• Ic 4 ctrl
• Ign 1 vol
• Ignition coil/ module 3 (top of engine, under cover at cylinder 3)
• Ignition coil/ module 4 (top of engine, under cover at cylinder 4)
• Knock sensor (left side of under rear side of intake)
• Ks sig
• Loc cont sig 1
• Low ref
• Low sens 2
• Low sig sens 1
• Low sig sens 2
• Map sens sig
• Nca
• Oil pres sw sig
• Purg sol ctrl
• S105
• Sol press sig
• Starting/charging system
• Tac mtr ctrl 1
• Tac mtr ctrl 2
• Tan
• Tp sens 1 sig
• Tp sens 2 sig

2.4L VIN B

2.4L VIN B, Engine Performance Wiring Diagram (1 of 4) for Pontiac G5 2007

List of elements for 2.4L VIN B, Engine Performance Wiring Diagram (1 of 4) for Pontiac G5 2007:

• (in engine compt, next to left strut tower) underhood fuse block
• (under left side of dash, at top of brake pedal) stop lamp/
• 5v ref 1
• 5v ref 2
• Acc
• Acc voltage
• Accelerator pedal position (app) sensor (near accelerator pedal bracket)
• Accy
• Air conditioning system
• App sensor 1
• App sensor 2
• Bat
• Body control module (bcm) (under center dash, on right side of center console)
• Cl rly ctrl
• Computer data lines system
• Cooling fans system
• Cpp switch sig
• Cruise ctrl sig
• Ecm/trans fuse 15a
• Engine control module (ecm) (left side of engine compt, in front of underhood fuse block)
• Evap sol ctrl
• Evaporative emission (evap) canister vent solenoid valve (under rear of vehicle, behind fuel tank attached to evap canister)
• Exterior lights system
• F pmp rly ctrl
• Fan rly ctrl
• Fuel level sens
• Fuel tank pressure (ftp) sensor (top of fuel tank)
• G101 (left side of engine compt, under coolant reservoir)
• Gmlan data
• Ground
• Hot at all times
• Hot in acc or run
• Hvac/ ip ign fuse 16 10a
• Ign
• Ign 1
• Ignition switch
• Instrument panel cluster (ipc)
• Logic
• Low ref
• Malfunc- tion indicator lamp
• Mil ctrl
• Off
• Pnk
• Power distribution system
• Press sens sig
• Pwr trn rly
• Red/pnk a
• Rly coil ctrl
• Run
• Run/ crank relay
• Start
• Starting/charging system
• Stop lp
• Tan
• Tcc switch
• Transmissions system

2.4L VIN B, Engine Performance Wiring Diagram (2 of 4) for Pontiac G5 2007

List of elements for 2.4L VIN B, Engine Performance Wiring Diagram (2 of 4) for Pontiac G5 2007:

• (in engine compt, next to left strut tower) underhood fuse block
• (top of engine) ignition coil/module
• (top, left side of engine) s103
• (under left side of dash, at top of clutch pedal) (m/t) clutch pedal position (cpp) switch
• A/c refrigerant pressure sensor (right front of engine compt, on a/c line near compressor)
• Ecm fuse 15a
• Emisn fuse 10a
• Evaporative emission (evap) canister purge solenoid valve (top, rear of engine)
• Fuel injectors (top, left side of engine, under fuel rail assembly)
• G107 (upper front, right side of engine, near exhaust)
• Hot at all times
• Inj fuse 10a
• Knock sensor (ks) (left side of engine, under rear side of intake)
• Nca
• Pnk
• Pwr/trn relay
• S140
• S141
• Tan
• Throttle actuator control (tac) module (top of intake manifold)

2.4L VIN B, Engine Performance Wiring Diagram (3 of 4) for Pontiac G5 2007

List of elements for 2.4L VIN B, Engine Performance Wiring Diagram (3 of 4) for Pontiac G5 2007:

• (rear, left side of engine, below exhaust) engine coolant temperature (ect) sensor
• (top front of engine, at cylinder 3 intake port runner) manifold absolute pressure (map) sensor
• 5v ref 1
• 5v ref 2
• C3 vss low signal
• Clutch start sw sig
• Cnstr vent fuse 10a
• Computer data lines system
• Cooling fans system
• Ect sens sig
• Engine control module (ecm) (left side of engine compt, in front of underhood fuse block)
• Evap sol
• Fan rly ctrl
• Fuel level sensor
• Fuel pump & sender assembly (inside fuel tank)
• Fuel pump fuse 15a
• Fuel pump motor
• Fuel pump relay
• G101 (left side of engine compt, under coolant reservoir)
• G402 (center of rear shelf, near speaker)
• Gen sig
• Gmlan data
• Hot at all times
• Low ref
• Map sens sig
• Not used) (68 to 73
• Oil press
• Pnk
• Press sens sig
• Starting/ charging system
• Tan
• Underhood fuse block (in engine compt, next to left strut tower)
• Vss high signal

2.4L VIN B, Engine Performance Wiring Diagram (4 of 4) for Pontiac G5 2007

List of elements for 2.4L VIN B, Engine Performance Wiring Diagram (4 of 4) for Pontiac G5 2007:

• (rear of engine compt, in exhaust manifold) heated oxygen sensor (ho2s) 1
• (rear of engine compt, in exhaust near catalytic converter) heated oxygen sensor (ho2s) 2
• (upper front, right side of engine, near camshaft cover) exhaust camshaft position (cmp) sensor
• (upper rear, left side of engine, near camshaft cover) intake camshaft position (cmp) sensor
• 5v ref 1
• 5v ref 2
• Ckp sens sig
• Cmp ctrl
• Cmp sens sig
• Crankshaft position (ckp) sensor (above starter motor)
• Engine control module (ecm) (left side of engine compt, in front of underhood fuse block)
• Engine oil pressure (eop) switch (left side of engine, above starter)
• Exhaust camshaft position (cmp) actuator solenoid (top of engine, between camshaft covers)
• G105 (lower left front of transmission case)
• Gnd
• Hall effect sensor
• Ho2s hi sig
• Ho2s lo ctrl
• Ho2s lo sig
• Iat sens sig
• Ic 1 ctrl
• Ic 2 ctrl
• Ic 3 ctrl
• Ic 4 ctrl
• Ign 1
• Ign 1 vol
• Inj 1 ctrl
• Inj 2 ctrl
• Inj 3 ctrl
• Inj 4 ctrl
• Intake camshaft position (cmp) actuator solenoid (top of engine, between camshaft covers)
• Ks sens sig
• Low ref
• Maf sens sig
• Mass air flow (maf)/intake air temperature (iat) sensor (on intake, after air cleaner)
• Nca
• Pnk
• Sens sig
• Tac motor
• Tan
• Tp sens 1
• Tp sens 2
• Vehicle speed sensor (vss) (m/t) (top of manual transmission)