GROUND DISTRIBUTION – Ford F550 Super Duty 2004 – SYSTEM WIRING DIAGRAMS

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram (1 of 4) for Ford F550 Super Duty 2004

List of elements for Ground Distribution Wiring Diagram (1 of 4) for Ford F550 Super Duty 2004:

• (6.8l) heated positive crankcase ventilation (pcv) element
• (at left rear side of engine compartment) auxiliary relay box 2
• (at left rear side of engine compt) (diesel) auxiliary relay box 5
• (at left rear side of engine compt) (except diesel) auxiliary relay box 4
• (behind lower left side of dash) central junction box (cjb)
• (diesel)
• (diesel) a/c clutch field coil
• (diesel) air filter sensor
• (diesel) dual pressure switch
• (diesel) fuel heater relay
• (diesel) fuel injector control module
• (diesel) powertrain control module (pcm)
• (except diesel)
• (except diesel) powertrain control module (pcm)
• (near breakout for injector driver module)
• A/c compressor clutch diode
• Abs control module
• Battery
• Battery 2
• Battery charge trailer tow relay
• Brake fluid level switch
• Breakout for c110)
• C1381a
• C1388c
• C175
• C270f
• C270h
• C290a
• Control harness, near breakout for left headlight)
• Crankshaft position sensor shield
• Data link connector (dlc)
• Daytime running lamps (drl) relay 1
• Daytime running lamps (drl) relay 2
• Engine compartment lamp
• Except diesel
• Except diesel, a/t
• G100 (at left rear side of engine compt)
• G101 (at left side of engine compt)
• G102 (at right side of engine compt)
• G104 (in engine compt, at right fender)
• G105 (at left front side of engine compt)
• G106 (diesel) (at right frame rail, in engine compt)
• G109 (at left side of engine)
• G200 (behind left side of dash)
• Left front fog lamp
• Left front park/ turn lamp
• Left front side lamp
• Left headlamp
• Left turn trailer tow relay
• Mass air flow (maf) sensor
• Nca
• Near breakout for g100)
• Parking lamp trailer tow relay
• Pcm power diode
• Pcm power relay
• Powertrain control module (pcm)
• Radio
• Reversing lamp trailer tow relay
• Right front fog lamp
• Right turn trailer tow relay
• S102 (in engine control harness, near breakout for g101)
• S106 (in engine control harness, near breakout for powertrain control module)
• S117 (diesel) (near break- out for powertrain control module)
• S145 (near breakout for c110)
• S161 (near crankshaft position sensor shield
• S167
• S195
• Starter relay
• Windshield wiper motor

Ground Distribution Wiring Diagram (2 of 4) for Ford F550 Super Duty 2004

List of elements for Ground Distribution Wiring Diagram (2 of 4) for Ford F550 Super Duty 2004:

• (behind left center of dash) auxiliary relay box 1
• (behind lower left side of dash) central junction box (cjb)
• (diesel)
• (diesel) auxiliary powertrain control module (apcm)
• (diesel: left side of engine compt) (except diesel: at left rear side of engine compt) (w/ electronic shift on the fly) auxiliary relay box 3
• (except diesel) powertrain control module (pcm)
• (not used)
• (w/ adjustable pedals)
• (w/ higher option content) ambient air temperature sensor
• 87a
• A/c clutch field coil
• Adjustable pedal switch
• Air bag sliding contact
• Brake pedal position switch
• Brake shift interlock
• C202b
• C205a
• C205b
• C218a
• C220c
• C270a
• C281a
• C290a
• C291a
• C294a
• C294b
• C294c
• Center roof marker lamp
• Data link connector (dlc)
• Diesel
• Diesel w/ higher option content
• Except diesel
• Except lariat
• Four- wheel drive control module
• Four- wheel drive switch
• Front cigar lighter
• Front function selector switch assembly
• Front heater blower motor resistor
• Fuel heater
• Fuel pump
• Fuel tank selector switch
• G108 (at right side of engine compt)
• G201 (behind left side of dash)
• G202 (behind left side of dash)
• G300 (on vehicle floor, in left front footwell)
• Glove box lamp
• Harness, near breakout for g108)
• Horn
• Indicator flasher relay
• Instrument cluster
• Instrument panel power point
• Lariat
• Left center roof marker lamp
• Left roof marker lamp
• Left vanity mirror lamp
• Main light switch
• Multi- function switch
• Nca
• Near breakout for instrument cluster)
• Overhead console
• Parking aid disable switch
• Parking aid module (pam)
• Parking brake switch
• Power sliding rear window switch
• Radio
• Rear window defrost relay
• Right center roof marker lamp
• Right front park/ turn lamp
• Right front side lamp
• Right headlamp
• Right roof marker lamp
• Right vanity mirror lamp
• Roof opening panel module
• S172 (except diesel w/ low option content) (in engine control harness, near breakout for left front wheel speed sensor)
• S217 (in main harness, near breakout for instrument cluster)
• S218 (in main harness, near breakout for instrument cluster)
• S232
• S250 (m/t: at breakout for left auxiliary relay box 3) (a/t: at breakout for c1010)
• S257 (in main harness, near breakout to temperature blend door actuator)
• S290 (in main harness, near breakout to radio)
• S904
• S920 (in roof marker lamp jumper harness, near breakout for right roof marker light)
• Speed control servo
• Steering wheel/ speed control switch
• Sunload sensor
• Temperature blend door actuator
• Trailer electronic brake control connector
• Transfer case high to low relay
• Transfer case low to high relay
• Vacuum pump motor
• W/ auxiliary fuel tank
• W/ electronic shift on the fly
• W/ higher option content
• W/ power equipment
• W/ roof opening panel
• W/o roof opening panel
• Windshield washer pump motor
• Windshield wiper motor

Ground Distribution Wiring Diagram (3 of 4) for Ford F550 Super Duty 2004

List of elements for Ground Distribution Wiring Diagram (3 of 4) for Ford F550 Super Duty 2004:

• (except california)
• (f450 diesel w/ pickup box) rear marker lamp assembly
• (in rear lamp connector harness, near breakout for c438) s402
• (not used)
• 4-pin trailer tow connector
• 7-pin trailer tow connector
• Chassis cab
• Class ii, iv w/ bumper
• Except chassis cab
• Except f450
• F450
• F450 diesel w/ pickup box
• Fuel tank unit
• G203 (under right side of dash)
• G400 (at vehicle underbody, chassis left side member)
• Left front running board lamp
• Left license plate lamp
• Left rear park/ stop/ turn lamp
• Left rear park/stop/ turn lamp
• Left rear running board lamp
• Left rear side lamp 1
• Left rear side lamp 2
• Left reversing lamp
• Nca
• Nca (california)
• Passenger air bag deactivation (pad) switch
• Pickup w/ box
• Pickup w/ box & dual rear wheels
• Pickup w/ box w/o dual rear wheels
• Pickup w/o box
• Pickup w/o box, f450 w/ 5th wheel
• Restraints control module
• Right front running board lamp
• Right license plate lamp
• Right rear park/stop/ turn lamp
• Right rear running board lamp
• Right rear side lamp 1
• Right rear side lamp 2
• Right reversing lamp
• S310 (near breakout for right rear running board light)
• S311 (in running board lamps harness, near breakout for left rear running board light)
• S401 (in taillamps harness, near breakout for g400)
• S402 (in rear lamp connector harness, near breakout for right rear park/ stop/turn light)
• S404 (in rear lamp connector harness, near breakout for c408)
• S404 (in taillamps harness, near breakout for g400)
• S432 (in trailer lamp feed harness, near breakout for c410)
• S463 (in rear license plate lamp harness, near breakout for c465)
• To left tail lamps
• To right tail lamps
• W/ rear bumper

Ground Distribution Wiring Diagram (4 of 4) for Ford F550 Super Duty 2004

List of elements for Ground Distribution Wiring Diagram (4 of 4) for Ford F550 Super Duty 2004:

• (late production)
• (w/ crew cab) rear interior/ map lamps assembly
• (w/ power equipment) driver side front door ajar switch
• (w/ power equipment) passenger side front door ajar switch
• (w/ power equipment) vehicle security module (vsm)
• (w/ rke)
• (w/ super cab)
• (w/o power equipment)
• (w/o power equipment) driver side front door ajar switch
• (w/o rke)
• (w/o super cab)
• C2113a
• C504a
• Crew cab
• Crew cab w/ power & heated seats
• Driver side door lock switch
• Driver side exterior rear view mirror
• Driver side front heated seat relay
• Driver side front seat adjust switch
• Driver side rear door ajar switch
• Driver side seat heater switch
• Except crew cab w/ power & heated seats
• Except crew cab w/ power equipment
• Exterior rear view mirror switch
• Front interior/ map lamps assembly
• G110 (at top left side of engine)
• G900 (at left "c" pillar)
• High mounted stoplamp
• Key pad switch assembly
• Left bank fuel injector shield
• Left front seat back heater
• Master window adjust switch
• Nca
• Passenger side door lock switch
• Passenger side exterior rear view mirror
• Passenger side front door ajar switch
• Passenger side front seat adjust switch
• Passenger side rear door ajar switch
• Passenger side seat heater switch
• Right bank fuel injector shield
• Right front seat back heater
• S233 (in body main harness, near grommet for right front door)
• S300 (in body main harness, near breakout for g900)
• S301 (near breakout for driver's side seat buckle)
• S306 (w/ memory: near breakout for c327) (w/ heated seats: near breakout for c3049) (w/o heated seats: near breakout for c3007)
• S332 (w/o memory: near breakout for driver safety belt buckle switch) (w/ memory: near breakout for c315)
• S355 (w/ power seats) s335 (w/o power seats) (in passenger-driver seat jumper harness, near breakout for passenger side seat heater switch)
• S501 (in body main harness, at breakout for driver side door lock switch)
• S639 (in body main harness, at breakout for right front door entry light)
• Safety belt buckle switch
• W/ crew cab
• W/ power equipment
• W/ rke
• W/o crew cab
• W/o heated seats
• W/o power equipment