POWER DISTRIBUTION – Ford F550 Super Duty 2000 – SYSTEM WIRING DIAGRAMS

POWER DISTRIBUTION

Power Distribution Wiring Diagram (1 of 4) for Ford F550 Super Duty 2000

List of elements for Power Distribution Wiring Diagram (1 of 4) for Ford F550 Super Duty 2000:

• (diesel only)
• (diesel w/o dual gen)
• (engne harn, near breakout to starter motor relay) s146
• (in back-up lamp harn, left rear of engine compt) s251
• (left rear of engine compt) bi-fuel relay module
• (left side of engine compt) battery junction box
• A/c clutch relay
• Anti-lock brake system module
• Battery junction box
• Battery junction box (left side of engine compt)
• Bi-fuel
• Bi-fuel power relay
• Blower motor relay
• Cold start heater relay
• Compuvalve module
• Daytime running lamps resistor
• Diesel
• Driver's seat regulator control switch
• From a fuse 23 (diagram 1 of 4)
• Fuel pump relay
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 25a
• Fuse 30a
• Fuse 3a
• Fuse 40a
• Fuse 5a (diesel w/ dual gen)
• Fuse 60a
• Gasoline
• Generator/ voltage regulator (diesel)
• Generator/ voltage regulator (gasoline)
• Generator/ voltage regulator (secondary: diesel w/ dual gen)
• Glow plug relay
• High to low relay
• I/p relay block
• Idm power relay (diesel)
• Left battery (diesel only)
• Low to high relay
• Manifold intake air heater relay
• Nca
• Pcm diode
• Pcm power relay
• Power point
• Radio
• Red
• Right battery
• S148 (near starter motor relay)
• S149 (near starter motor relay)
• Starter motor
• Starter motor relay
• To fuse 17 (diagram 1 of 4)
• To fuse 26 (diagram 2 of 4)
• To fuse 30 (diagram 2 of 4)
• Trailer back-up lamps relay
• Trailer battery charge relay
• Trailer brakes feed (taped in harness)
• Trailer running lamps relay
• Trailer tow relay block
• Transfer case shift relay
• Washer pump relay

Power Distribution Wiring Diagram (2 of 4) for Ford F550 Super Duty 2000

List of elements for Power Distribution Wiring Diagram (2 of 4) for Ford F550 Super Duty 2000:

• (engine harness, pia diesel harness) s154
• (main harn, behind left side of dash) s210
• (main harn, behind left side of dash) s212
• (main harn, center of dash) s230
• (main harn, lower left side of dash) s214
• Acc
• Accessory delay relay
• All lock relay
• All unlock relay
• Battery junction box (left side of engine compt)
• C242a
• C242b
• Central junction box
• Central junction box (lower left side of dash)
• Circuit breaker 30a
• Coil on plug 1
• Coil on plug 10
• Coil on plug 2
• Coil on plug 3
• Coil on plug 4
• Coil on plug 5
• Coil on plug 6
• Coil on plug 7
• Coil on plug 8
• Coil on plug 9
• Driver unlock relay
• From b fuse 4 (diagram 1 of 4)
• From pcm power relay (diagram 1 of 4)
• Fuel heater
• Fuse 15a
• Fuse 20a
• Fuse 30a
• Fuse 30a (5.4l gasoline)
• Fuse 30a (6.8l gasoline)
• Fuse 30a (diesel)
• Fuse 50a
• Ignition switch
• Left power door lock switch
• Lock
• Main light switch
• Multi- function switch
• Nca
• Off
• Park lamp relay
• Radio capacitor 1
• Radio noise capacitor 2
• Right power door lock switch
• Rke relay box
• Run
• S130 (engine harn, near throttle body)
• S135 (engine harness, right side of engine block)
• S179 (engine harn, left side of engine compartment)
• Start
• To fuse 10 (diagram 4 of 4)
• To fuse 13 (diagram 3 of 4)
• To fuse 19 (diagram 3 of 4)
• To fuse 20 (diagram 4 of 4)
• To fuse 22 (diagram 4 of 4)
• To fuse 27 (diagram 4 of 4)
• W/ rke
• W/o rke
• Wastegate solenoid control

Power Distribution Wiring Diagram (3 of 4) for Ford F550 Super Duty 2000

List of elements for Power Distribution Wiring Diagram (3 of 4) for Ford F550 Super Duty 2000:

• (main harness, top left side of dash) s213
• (near brake pedal position switch) s221
• 87a
• Accessory delay relay
• Air bag diagnostic module
• Auxiliary powertrain control module
• Brake pedal position switch
• Brake pressure switch
• C240a
• C242a
• C242b
• C250a
• C250b
• Central junction box (lower left side of dash)
• Cigar lighter
• Clutch pedal position switch
• Dash reset relay
• Data link connector
• Engine compartment lamp
• Flasher relay
• From fuse 22 (power distribution box) (diagram 2 of 4)
• From fuse 3 k (diagram 3 of 4)
• From h fuse 30 (diagram 2 of 4)
• Front map lamp
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 5a
• G206 (center of dash)
• Generic electronic module
• Generic electronic module (gem)
• Glove compartment lamp
• Horn relay
• I/p relay block
• Idle validation switch
• Instrument cluster
• Interior lamp relay
• Nca
• Overdrive cancel switch
• Overhead trip computer module
• Power mirror switch
• Powertrain control module
• Rear map lamp
• S229 (main harn, top left side of dash)
• S242 (main harness, near breakout to customer access)
• S290 (main harness, near breakout to customer access)
• S906 (main harn, left rear of cab)
• To fuse 4 (diagram 3 of 4)
• W/ bi-fuel
• W/o bi-fuel

Power Distribution Wiring Diagram (4 of 4) for Ford F550 Super Duty 2000

List of elements for Power Distribution Wiring Diagram (4 of 4) for Ford F550 Super Duty 2000:

• (engine harn, left rear of engine compt) s124
• (engine harness, near breakout to power distribution box)
• (main harn, left side of dash) s206
• (main harn, left side of dash) s235
• A/t
• Air bag diagnostic module
• Anti-lock brake system module
• Back-up lamp switch
• Battery junction box
• Blend door actuator
• Blower motor relay
• C242a
• C242b
• Central junction box (lower left side of dash)
• Clutch pedal position switch or clutch pedal position switch jumper
• Customer access (taped in harness)
• Daytime running lamp relay 2
• Daytime running lamp relay block
• Digital transmission range sensor
• Flasher relay
• From ignition switch (diagram 2 of 4)
• Fuel tank selector switch
• Function selector switch
• Fuse (not used)
• Fuse 10a
• Fuse 15a
• Fuse 30a
• Fuse 5a
• Generic electronic module (gem)
• I/p relay block
• M/t
• Main light switch
• Passenger's air bag deactivation switch
• Radio
• Red
• S119
• S203 (main harn, center of dash)
• Shift lock actuator
• Speed control module
• Tan/red
• Trailer battery charge relay
• Trailer tow relay block
• Vacuum hublock solenoid
• Vacuum pump
• Washer pump relay
• Windshield wiper motor
• Wiper hi/lo relay
• Wiper run/ park relay