TRANSMISSION – Chevrolet Malibu SS 2006 – SYSTEM WIRING DIAGRAMS

TRANSMISSION

2.2L VIN F

2.2L VIN F, A/T Wiring Diagram (1 of 2) for Chevrolet Malibu SS 2006

List of elements for 2.2L VIN F, A/T Wiring Diagram (1 of 2) for Chevrolet Malibu SS 2006:

• 1-2 shift sol
• 1-2 shift solenoid (1-2 ss) valve
• 2-3 shift sol
• 2-3 shift solenoid (2-3 ss) valve
• 5v ref
• A/t iss hi sig
• A/t iss lo sig
• App sens 1 sig
• App sens sig
• Automatic transaxle
• Automatic transaxle fluid pressure manual valve position switch
• Automatic transaxle fluid temperature sensor
• Automatic transaxle input shaft speed sensor
• Battery in
• Computer data lines system
• D12
• Ect sens sig
• Engine coolant temperature (ect) sensor (on top rear of engine)
• Etc fuse 15a
• G105 (right rear (right rear of engine, on engine to transmission stud)
• Gmlan data
• Gnd
• Hot at all times
• Hot in run or start
• Hot with powertrain relay energized
• Hot with run/crank relay energized
• Ignition (1) in
• Info not available
• Instrument panel cluster
• Lo reference
• Logic
• Low ref
• Malfunction indicator lamp
• Mil ctrl
• Pc sol hi
• Pc sol lo
• Pcm fuse 13 10a
• Pcm ign1 fuse 10a
• Pnk
• Powertrain control module (pcm) (front of battery)
• Pressure control (pc) solenoid valve
• Red
• Rev,d,2,1
• S103
• Stop lp sw
• Tan
• Tap up/down sig
• Tcc pwm sol
• Tcc release
• Tcc release sig
• Tft sensor sig
• Torque converter clutch pulse width modulation (tcc pwm) solenoid valve
• Tr sw in-a
• Tr sw in-b
• Tr sw in-c
• Tr sw in-p
• Trans fuse 4 10a
• Trans range b
• Trans range c
• Underhood fuse block (on left side of engine compt)
• Vehicle speed sensor (vss) (on transmission)
• Vss hi (signal)
• Vss lo (ground)

2.2L VIN F, A/T Wiring Diagram (2 of 2) for Chevrolet Malibu SS 2006

List of elements for 2.2L VIN F, A/T Wiring Diagram (2 of 2) for Chevrolet Malibu SS 2006:

• (below center console shifter) a/t shift lock control solenoid
• 5v ref
• Accelerator pedal position (app) sensor (attached to accelerator pedal)
• Body control module (bcm) (below right side of dash, near blower motor)
• Brake pedal position sens sig
• Brake pedal position sensor (on brake pedal support)
• Computer data lines system
• G105 (right rear of engine, on engine to transmission stud)
• G303 (left kick panel)
• Gmlan data +
• Gmlan data -
• Hot in run or start
• Logic
• Low ref
• Park/neutral position (pnp) switch (on top of transmission)
• Pnk
• Run/ crank fuse 2a
• Tan
• Tap enable sig
• Tap up/ tap down switch

3.5L

3.5L, A/T Wiring Diagram (1 of 2) for Chevrolet Malibu SS 2006

List of elements for 3.5L, A/T Wiring Diagram (1 of 2) for Chevrolet Malibu SS 2006:

• 1-2 shift sol
• 1-2 shift solenoid (1-2 ss) valve
• 2-3 shift sol
• 2-3 shift solenoid (2-3 ss) valve
• A/t sensor hi
• A/t sensor lo
• Automatic transaxle
• Automatic transaxle fluid pressure manual valve position switch
• Automatic transaxle fluid temperature sensor
• Automatic transaxle input shaft speed sensor
• Battery in
• Computer data lines system
• Ect sensor in
• Engine controls system
• Engine coolant temperature (ect) sensor (left side of rear cylinder head, above transmission)
• Etc fuse 15a
• Exterior lights system
• G105 (right rear of engine, on engine to transmission stud)
• Gmlan data
• Gnd
• Hot at all times
• Hot in run or start
• Hot w/ run/crank relay energized
• Hot with powertrain relay energized
• Ignition (1) in
• Instrument panel cluster
• Logic
• Low ref
• Malfunction indicator lamp
• Mil ctrl
• Pc sol hi
• Pc sol lo
• Pcm fuse 13 10a
• Pcm ign1 fuse 10a
• Pnk
• Powertrain control module (pcm) (front of battery)
• Pressure control (pc) solenoid valve
• Red
• Rev,d,2,1
• S103
• Stop lp sw
• Tan
• Tap sw sig
• Tcc pwm sol
• Tcc release
• Tcc release in
• Tft sensor gnd
• Tft sensor in
• Torque converter clutch pulse width modulation (tcc pwm) solenoid valve
• Tr sw in-a
• Tr sw in-b
• Tr sw in-c
• Tr sw in-p
• Trans fuse 4 10a
• Trans press sig b
• Trans range c
• Underhood fuse block (on left side of engine compartment)
• Vehicle speed sensor (vss) (on transmission)
• Vss hi (signal)
• Vss lo (ground)

3.5L, A/T Wiring Diagram (2 of 2) for Chevrolet Malibu SS 2006

List of elements for 3.5L, A/T Wiring Diagram (2 of 2) for Chevrolet Malibu SS 2006:

• (below center console shifter) a/t shift lock control solenoid
• 5v ref
• Accelerator pedal position (app) sensor (attached to accelerator pedal)
• App sens 1
• App sens 2
• Body control module (bcm) (below right side of dash, near blower motor)
• Brake pedal position sens sig
• Brake pedal position sensor (on brake pedal support)
• Computer data lines system
• Down
• G105 (right rear of engine, on engine to transmission stud)
• G303 (left kick panel)
• Gmlan data +
• Gmlan data -
• Hot in run or start
• Ign 1
• Logic
• Low ref
• Park/neutral position (pnp) switch (on top of transmission)
• Pnk
• Run/ crank fuse 2a
• Serial data(p)
• Serial data(s)
• Stop lp sw
• Tan
• Tap enable sig
• Tap up/ tap down switch
• Throttle actuator control (tac) module (on intake manifold)

3.9L VIN 1

3.9L VIN 1, A/T Wiring Diagram for Chevrolet Malibu SS 2006

List of elements for 3.9L VIN 1, A/T Wiring Diagram for Chevrolet Malibu SS 2006:

• (below center console shifter)
• (left side of engine compartment, in front of battery) engine control module(ecm)
• 1-2 shift solenoid (1-2 ss) valve
• 1-2 ss vlv ctrl
• 10a
• 2-3 shift solenoid (2-3 ss) valve
• 2-3 ss vlv ctrl
• A/t shift lock control assembly
• A8 c3
• Acc voltage
• At iss high ctrl
• At iss low sig
• Automatic transmission fluid temperature(tft) sensor (in automatic transmission)
• Automatic transmission
• Automatic transmission input shaft speed (at iss) sensor
• B(+)
• Body control module (bcm) (below right side of dash, near blower motor)
• C9 pnk
• Computer data lines system
• Down
• Engine controls system
• G105
• G303
• Gmlan bus (+)
• Gmlan bus (-)
• Gmlan data
• Gnd
• Hot at all times
• Hot in run or start
• If equipped
• Ign 1 voltage
• Instrument panel cluster (ipc)
• Internal mode switch (ims)
• Logic
• Low reference
• Malfunction indicator lamp
• Mil control
• P/n sig
• Pc sol hi ctrl
• Pc sol valv lo ctrl
• Pnk
• Pressure control (pc) solenoid valve
• Red
• Run/ crank fuse 2a
• S103
• Stop lmp sw sig
• Stop sw sig
• Tan
• Tap enable sig
• Tap up/down swi sig
• Tap up/tap down switch
• Tcc pwm vlv ctrl
• Tcc release
• Tcc release sw sig
• Tcm fuse
• Tft sens sig
• Torque converter clutch pulse width modulation (tcc pwm) solenoid valve
• Torque converter clutch release switch
• Trans fuse 10a
• Trans sw sig p
• Trans swi sig a
• Trans swi sig c
• Trans switch sig b
• Transmission control module (in left rear of engine compartment, near strut tower)
• Underhood fuse block (on left side of engine compartment)
• Vehicle speed sensor (vss) (on transmission)
• Vss high sig
• Vss low sig