TRANSMISSION – Chevrolet Tahoe 1996 – SYSTEM WIRING DIAGRAMS

TRANSMISSION

5.7L

5.7L (VIN R), Transmission Wiring Diagram, 4L60-E for Chevrolet Tahoe 1996

List of elements for 5.7L (VIN R), Transmission Wiring Diagram, 4L60-E for Chevrolet Tahoe 1996:

• (2wd only)
• (4wd only)
• (left side of transmission-2wd) (left side of transfer case-4wd)
• 1-2 shift sol
• 1-2 shift solenoid
• 2-3 shift sol
• 2-3 shift solenoid
• 3-2 ctrl solenoid
• 3-2 downshift sol
• 4wd low signal in
• 5v reference
• Automatic transmission (4l60-e)
• Battery in
• Brake fuse 18 10a
• Brake switch input
• Dash fuse block
• Data class ii
• Data link connector (under left side of dash)
• Ecm 1 fuse 20a
• Ecm b fuse 20a
• Ect sens input
• Electronic brake control module
• Eng 1 fuse 20a
• Engine coolant temp sensor (top right front of engine)
• Front wheel lock
• Fuel injectors, ignition control moudule & ignition coil
• Fuel pump & oil press switch/ sender & fuel pump relay
• G120 (top of right cylinder head)
• Gauges fuse 4 10a
• Hot at all times
• Hot in off, run or start
• Hot in run
• Hot in run or start
• Ignition in
• Instrument cluster
• Maf sensor & heated oxygen sensors
• Malfunction indicator lamp
• Mil control
• Pcm ground
• Pcs sol hi out
• Pcs sol lo out
• Pnk
• Press ctrl solenoid
• Range signal "a"
• Range signal "b"
• Range signal "c"
• Red
• S101
• S103
• S108
• S150 (engine harn, 13 cm from bpmv break-out)
• S151
• S161
• S213
• S231 (engine harness, near map or egr break-out)
• Sensor ground
• Sensor return
• Solenoid
• Stoplamp switch (on brake pedal bracket)
• Tan
• Tcc
• Tcc pwm
• Tcc pwm sol
• Tcc sol
• Throttle position sensor (mounted to side of throttle body)
• Tp sens input
• Trans fluid temp sensor
• Trans fuse 20 10a
• Trans range pressure switch assembly
• Trans range switches
• Trans temp sig in
• Transfer case & axle switches (4wd only)
• Transfer case circuit
• Underhood fuse/relay center
• Vehicle control module (left side of engine compt)
• Vehicle speed sensor
• Vehicle speed sensor adaptor (4wd only)
• Vss hi
• Vss lo

Transfer Case Wiring Diagram for Chevrolet Tahoe 1996

List of elements for Transfer Case Wiring Diagram for Chevrolet Tahoe 1996:

• (4wd harn, 79 cm from engine harn breakout)
• (a/t)
• (all)
• (diesel)
• (engine harness, near taillamp harn breakout) s111
• (exc diesel)
• (left side of dash) convenience center
• (right rear of front drive axle)
• 4wd fuse 24 25a
• 4wd indicator
• 87a
• Auxiliary battery relay (exc diesel)
• Diesel
• Front axle actuator (right rear of front drive axle)
• Front axle switch
• G119 (right front of engine)
• G202 (left side of dash)
• Gasoline
• Hot in run
• Hot with headlamp sw in park or head
• I/p fuse block (left side of dash)
• Illum fuse 14 10a
• Interior lights system
• Powertrain control module (diesel) (behind right side of dash)
• Red
• S204
• S217
• S235 (exc diesel)
• S253
• S259 (cross- body harness)
• S302
• S313
• S314 (4wd harn, 5 cm from transfer case breakout)
• Spare power source
• Transfer case mode selector illumination lamp
• Transfer case relay (k3500 only) (right side of firewall)
• Transfer case switch (top left of transfer case)
• Transfer case synchronizer (k3500 only) (top of transfer case)
• Vehicle control module (gasoline) (left side of engine compt)

Transfer Case Wiring Diagram, with Electronic Shift Control for Chevrolet Tahoe 1996

List of elements for Transfer Case Wiring Diagram, with Electronic Shift Control for Chevrolet Tahoe 1996:

• +8v ref
• 2 hi indic ctrl
• 2 hi select sw in
• 2-hi ind
• 2-hi sw
• 4 hi indic ctrl
• 4 hi select sw in
• 4 lo indic ctrl
• 4 lo sw
• 4 low select sw in
• 4-hi ind
• 4-hi sw
• 4-lo ind
• 4wd fuse 24 25a
• 5v reference
• Battery in
• C10
• C11
• C12
• C13
• C14
• C15
• C16
• Channel a
• Channel b
• Channel c
• Channel p
• D10
• D11
• D12
• D13
• D14
• D15
• D16
• Data link connector (partial) (under left side of dash)
• Diagnostics enable
• Diesel
• Encoder channel a
• Encoder channel b
• Encoder channel c
• Encoder channel p
• Encoder ground
• Front axle actuator
• Front axle switch
• G119 (right front of engine)
• G202 (left side of dash)
• Gasoline
• Gauges fuse 4 10a
• Gnd
• Ground
• Hot at all times
• Hot in run
• Hot in run or start
• I/p fuse block
• Ignition in
• Illumination lamp
• Interior lights system
• Park/neutral position switch (on left side, center of transmission)
• Pnk
• Pnp switch out
• Powertrain control module (left fender apron)
• Rear liftgate window release circuit
• Red
• S111 (engine harn, near tail- lamp harness break-out)_
• S162
• S162 (gas) s107 (diesel)
• S204
• S213
• S235
• S270
• S271 (i/p harness, 5 cm inside crossbody harness)
• S298
• S313 (4wd harness, 79 cm from engine harness break-out)
• Tcase fuse 2 20a
• Tcc/stop lamp switch (top of brake pedal)
• Trans case mtr
• Trans- mission circuit
• Transfer case control module (under left side of dash)
• Transfer case encoder (right side center of transfer case)
• Transfer case encoder motor (center right side of transfer case)
• Transfer case select switch
• Transfer case switch (top left of transfer case)
• Turn b/u fuse 16 20a
• Vss in

6.5L

6.5L (VIN F), Transmission Wiring Diagram for Chevrolet Tahoe 1996

List of elements for 6.5L (VIN F), Transmission Wiring Diagram for Chevrolet Tahoe 1996:

• (2wd only)
• (4wd only)
• (i/p harn, 4 cm from engine harn break-out)
• 1-2 shift sol
• 1-2 shift solenoid
• 2-3 shift sol
• 2-3 shift solenoid
• 4wd low signal in
• A/t iss sens hi in
• A/t iss sens in
• A/t iss sens lo in
• A/t iss sensor out
• A12
• Accelerator pedal position module (part of accelerator pedal)
• App 1 5v ref
• App 1 signal in
• App 2 5v ref
• App 2 signal in
• App 3 5v ref
• App 3 signal in
• Automatic transmission
• Automatic transmission input shaft speed sensor (left front of transmission)
• B10
• B12
• Battery in
• Brake fuse 18 10a
• Brake switch assembly (on brake pedal bracket)
• Brake switch in
• C11
• C12
• C13
• C14
• C15
• Class ii data
• D11
• D12
• D13
• Data link connector (under left side of dash)
• Ecm 1 fuse 20a
• Ecm b fuse 20a
• Ect sensor in
• Engine coolant temp sensor (near thermostat housing)
• Front wheel lock
• Fuel pump & oil press switch/ sender & fuel pump relay
• G120 (right top of cylinder head)
• Gauges fuse 4 10a
• Ground
• Hot at all times
• Hot in run
• Hot in run or start
• Hot in run, bulb test or start
• I/p fuse block
• Ignition in
• Instrument cluster
• Malfunction indicator lamp
• Mil control
• Pcm ground
• Pcs sol hi out
• Pcs sol lo out
• Pnk
• Power
• Powertrain control module (right side of dash near blower motor)
• Press ctrl
• Red
• S101
• S103
• S140 (engine sensor harness)
• S150 (engine harness, 13 cm from bpmv harness break-out)
• S152 (engine harn, 4 cm from i/p break-out)
• S211
• S213
• S220 (i/p harn, 12 cm from brake switch connector)
• S299
• Sensor ground
• Solenoid
• Stop/haz fuse 1 20a
• Stoplamp switch in
• Tan
• Tcc pwm
• Tcc pwm sol
• Tft sensor in
• Trans fluid temp sensor
• Trans fuse 20 10a
• Trans range "a"
• Trans range "b"
• Trans range "c"
• Trans range pressure switch assembly
• Trans range switches
• Transfer case & axle switches
• Transfer case circuit
• Turn/ hazard switch & chime module
• Underhood fuse/relay center
• Vehicle speed sensor (on transmission-2wd) (on transfer case-4wd)
• Vehicle speed sensor (vss) adaptor (4wd only)
• Vehicle speed sensor buffer (right side of dash)
• Vss hi in
• Vss in
• Vss lo in
• Vss out

Transfer Case Wiring Diagram for Chevrolet Tahoe 1996

List of elements for Transfer Case Wiring Diagram for Chevrolet Tahoe 1996:

• (4wd harn, 79 cm from engine harn breakout)
• (a/t)
• (all)
• (diesel)
• (engine harness, near taillamp harn breakout) s111
• (exc diesel)
• (left side of dash) convenience center
• (right rear of front drive axle)
• 4wd fuse 24 25a
• 4wd indicator
• 87a
• Auxiliary battery relay (exc diesel)
• Diesel
• Front axle actuator (right rear of front drive axle)
• Front axle switch
• G119 (right front of engine)
• G202 (left side of dash)
• Gasoline
• Hot in run
• Hot with headlamp sw in park or head
• I/p fuse block (left side of dash)
• Illum fuse 14 10a
• Interior lights system
• Powertrain control module (diesel) (behind right side of dash)
• Red
• S204
• S217
• S235 (exc diesel)
• S253
• S259 (cross- body harness)
• S302
• S313
• S314 (4wd harn, 5 cm from transfer case breakout)
• Spare power source
• Transfer case mode selector illumination lamp
• Transfer case relay (k3500 only) (right side of firewall)
• Transfer case switch (top left of transfer case)
• Transfer case synchronizer (k3500 only) (top of transfer case)
• Vehicle control module (gasoline) (left side of engine compt)

Transfer Case Wiring Diagram, with Electronic Shift Control for Chevrolet Tahoe 1996

List of elements for Transfer Case Wiring Diagram, with Electronic Shift Control for Chevrolet Tahoe 1996:

• +8v ref
• 2 hi indic ctrl
• 2 hi select sw in
• 2-hi ind
• 2-hi sw
• 4 hi indic ctrl
• 4 hi select sw in
• 4 lo indic ctrl
• 4 lo sw
• 4 low select sw in
• 4-hi ind
• 4-hi sw
• 4-lo ind
• 4wd fuse 24 25a
• 5v reference
• Battery in
• C10
• C11
• C12
• C13
• C14
• C15
• C16
• Channel a
• Channel b
• Channel c
• Channel p
• D10
• D11
• D12
• D13
• D14
• D15
• D16
• Data link connector (partial) (under left side of dash)
• Diagnostics enable
• Diesel
• Encoder channel a
• Encoder channel b
• Encoder channel c
• Encoder channel p
• Encoder ground
• Front axle actuator
• Front axle switch
• G119 (right front of engine)
• G202 (left side of dash)
• Gasoline
• Gauges fuse 4 10a
• Gnd
• Ground
• Hot at all times
• Hot in run
• Hot in run or start
• I/p fuse block
• Ignition in
• Illumination lamp
• Interior lights system
• Park/neutral position switch (on left side, center of transmission)
• Pnk
• Pnp switch out
• Powertrain control module (left fender apron)
• Rear liftgate window release circuit
• Red
• S111 (engine harn, near tail- lamp harness break-out)_
• S162
• S162 (gas) s107 (diesel)
• S204
• S213
• S235
• S270
• S271 (i/p harness, 5 cm inside crossbody harness)
• S298
• S313 (4wd harness, 79 cm from engine harness break-out)
• Tcase fuse 2 20a
• Tcc/stop lamp switch (top of brake pedal)
• Trans case mtr
• Trans- mission circuit
• Transfer case control module (under left side of dash)
• Transfer case encoder (right side center of transfer case)
• Transfer case encoder motor (center right side of transfer case)
• Transfer case select switch
• Transfer case switch (top left of transfer case)
• Turn b/u fuse 16 20a
• Vss in