TRANSMISSION – Dodge Cab & Chassis R2500 1998 – SYSTEM WIRING DIAGRAMS

TRANSMISSION

5.9L

5.9L 12-Valve Diesel, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2500 1998

List of elements for 5.9L 12-Valve Diesel, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2500 1998:

• (left fender side shield) g100
• (left kick panel) g200
• 4x4 ind
• 4x4 switch (on front axle tube)
• A14
• Brake sw sense
• Ccd (+)
• Ccd (-)
• Data link connector (partial) (left bottom of dash)
• Ect sens sig
• Eng speed sens sig
• F18
• Fuel pump & automatic shutdown relays
• Fuse 10a
• Fused b(+)
• Fused ign (st/run)
• G125 (front of eng)
• G200 (left kick panel)
• Generator output
• Gnd
• Gov press sig
• Hot at all times
• Hot in run or start
• Instrument cluster
• Joint connector
• Joint connector 1
• Joint connector 3
• Junction block
• K125
• K22
• K24
• K30
• K54
• K88
• Mil ind
• Od lamp driver
• Od sol ctrl
• Ou shft spd sig
• Out shaft spd gnd
• Over- drive off ind
• Overdrive switch
• Pnk
• Pnp sw sense
• Powertrain control module (in eng compt, on right side of firewall)
• S107
• S126
• Sensor gnd
• Stop lamp switch (top of brake pedal bracket)
• T13
• T14
• T18
• T25
• T41
• T54
• T60
• Tcc sol ctrl
• Tp sens sig
• Trans od sw sense
• Trans rly ctrl
• Trans temp sens
• Transmission output shaft speed sensor (on left side of transmission)
• V40
• Var sol ctrl
• Vss signal
• Z12

5.9L 12-Valve Diesel, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2500 1998

List of elements for 5.9L 12-Valve Diesel, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2500 1998:

• (eng harn, near branch to fuel heater)
• Controller anti- lock brake (2wd: on left front inner fender, 4wd: mounted on top of hydraulic control unit)
• Engine controls system
• Engine coolant temperature sensor (on left side of cylinder head, at rear end)
• Engine speed sensor (on front of eng, in timing chain case/cover)
• Engine starter motor relay
• Fuse 20a
• Fuse m 10a
• Generator
• Governor pressure signal
• Hot at all times
• Joint connector
• Overdrive solenoid control
• Park/ neutral position switch (on left side of transmission)
• Pnk
• Power distribution center
• Power distribution center
• Red
• S116 (eng harn, rear of eng on dash panel)
• S118
• S119 (eng harn, rear of eng on dash panel)
• S121 (eng harn, top of eng)
• S127 (eng harn, rear of eng on dash panel)
• Sensor ground
• Throttle position sensor (on top of injection pump)
• Torque converter clutch solenoid control
• Trans ctrl rly output
• Transmission control relay
• Transmission solenoid assembly (transmission)
• Transmission temperature sensor signal
• Variable force solenoid control

5.9L 24-Valve Diesel, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2500 1998

List of elements for 5.9L 24-Valve Diesel, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2500 1998:

• 4x4 ind
• 4x4 switch (on front axle tube)
• A14
• Brake sw sense
• Ccd (+)
• Ccd (-)
• Ckp sig
• Csi receive
• D20
• D21
• Data link connector (partial) (left bottom of dash)
• Ect sig
• Eng speed sens sig
• Engine control module
• Engine control module (left side of eng, behind fuel filter)
• F18
• Fuse 10a
• Fused b(+)
• Fused ign (st/run)
• G100 (left fender side shield)
• G125 (front of eng)
• G200 (left kick panel)
• Generator output
• Gnd
• Gov press sig
• Hot at all times
• Hot in run or start
• Instrument cluster
• Joint connector 1
• Joint connector 3
• Joint connector 6
• Joint connector 7
• Junction block
• K104
• K124
• K125
• K14
• K22
• K24
• K30
• K54
• K88
• Mil ind
• Od lamp driver
• Od sol ctrl
• Ou shft spd sig
• Out shaft spd gnd
• Over- drive off ind
• Overdrive switch
• Pnk
• Pnp sw sense
• Powertrain control module (in eng compt, on right side of firewall)
• S130
• S162
• Sci transit
• Sensor gnd
• Sensor ground
• Stop lamp switch (top of brake pedal bracket)
• T13
• T14
• T18
• T25
• T41
• T54
• T60
• Tcc sol ctrl
• Tp sens sig
• Tps sig
• Trans od sw sense
• Trans rly ctrl
• Trans temp sens
• Transmission output shaft speed sensor (on left side of transmission)
• V40
• Var sol ctrl
• Vss signal
• Z12

5.9L 24-Valve Diesel, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2500 1998

List of elements for 5.9L 24-Valve Diesel, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2500 1998:

• (eng harn, near branch to fuel heater)
• Controller anti- lock brake (2wd: on left front inner fender, 4wd: mounted on top of hydraulic control unit)
• Engine controls system
• Engine coolant temperature sensor (on left side of cylinder head, at rear end)
• Engine speed sensor (on front of eng, in timing chain case/cover)
• Engine starter motor relay
• Fuse 20a
• Fuse m 10a
• Generator
• Governor pressure signal
• Hot at all times
• Joint connector
• Overdrive solenoid control
• Park/ neutral position switch (on left side of transmission)
• Pnk
• Power distribution center
• Power distribution center
• Red
• S116 (eng harn, rear of eng on dash panel)
• S118
• S127 (eng harn, rear of eng on dash panel)
• S165
• Sensor ground
• Torque converter clutch solenoid control
• Trans ctrl rly output
• Transmission control relay
• Transmission solenoid assembly (transmission)
• Transmission temperature sensor signal
• Variable force solenoid control

5.9L, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2500 1998

List of elements for 5.9L, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2500 1998:

• (left fender side shield) g100
• (left kick panel) g200
• 4x4 ind
• 4x4 switch (on front axle tube)
• A14
• Brake sw sense
• Ccd (+)
• Ccd (-)
• Data link connector (partial) (left bottom of dash)
• Ect sens sig
• F18
• Fuel pump & automatic shutdown relays
• Fuse 10a
• Fused b(+)
• Fused ign (st/run)
• G125 (front of eng)
• G200 (left kick panel)
• Generator output
• Gnd
• Gov press sig
• Hot at all times
• Hot in run or start
• Instrument cluster
• Joint connector
• Joint connector 1
• Joint connector 3
• Junction block
• K125
• K22
• K30
• K54
• K88
• Mil ind
• Od lamp driver
• Od sol ctrl
• Ou shft spd sig
• Out shaft spd gnd
• Over- drive off ind
• Overdrive switch
• Pnk
• Pnp sw sense
• Powertrain control module (in eng compt, on right side of firewall)
• S107
• S126
• Sensor gnd
• Stop lamp switch (top of brake pedal bracket)
• T13
• T14
• T18
• T25
• T41
• T54
• T60
• Tcc sol ctrl
• Tp sens sig
• Trans od sw sense
• Trans rly ctrl
• Trans temp sens
• Transmission output shaft speed sensor (on left side of transmission)
• V40
• Var sol ctrl
• Vss signal
• Z12

5.9L, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2500 1998

List of elements for 5.9L, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2500 1998:

• (eng harn, 3.9l, 5.2l & 5.9l: rear of eng, top of bellhousing; 8.0l: rear of eng in branch to transmission) s125
• Controller anti- lock brake (2wd: on left front inner fender, 4wd: mounted on top of hydraulic control unit)
• Engine controls system
• Engine coolant temperature sensor (on thermostat housing)
• Engine starter motor relay
• Fuse 20a
• Fuse m 10a
• Generator
• Governor pressure signal
• Hot at all times
• Joint connector
• Overdrive solenoid control
• Park/ neutral position switch (on left side of transmission)
• Pnk
• Power distribution center
• Power distribution center
• Red
• S116 (eng harn, 3.9l, 5.2l & 5.9l: rear of eng, on firewall; 8.0l: rear of eng)
• S118 (eng harn, 3.9l, 5.2l, & 5.9l: rear of eng, center of firewall; 8.0l: rear of eng)
• S119 (eng harn, 3.9l, 5.2l, & 5.9l: rear of eng, center of firewall; 8.0l: rear of eng)
• S121 eng harn, near fuel inj 5 breakout)
• S127 (eng harn, top center of transmission)
• Sensor ground
• Throttle position sensor (on throttle body)
• Torque converter clutch solenoid control
• Trans ctrl rly output
• Transmission control relay
• Transmission solenoid assembly (transmission)
• Transmission temperature sensor signal
• Variable force solenoid control

8.0L

8.0L, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2500 1998

List of elements for 8.0L, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2500 1998:

• (left fender side shield) g100
• (left kick panel) g200
• 4x4 ind
• 4x4 switch (on front axle tube)
• A14
• Brake sw sense
• Ccd (+)
• Ccd (-)
• Data link connector (partial) (left bottom of dash)
• Ect sens sig
• F18
• Fuel pump & automatic shutdown relays
• Fuse 10a
• Fused b(+)
• Fused ign (st/run)
• G125 (front of eng)
• G200 (left kick panel)
• Generator output
• Gnd
• Gov press sig
• Hot at all times
• Hot in run or start
• Instrument cluster
• Joint connector
• Joint connector 1
• Joint connector 3
• Junction block
• K125
• K22
• K30
• K54
• K88
• Mil ind
• Od lamp driver
• Od sol ctrl
• Ou shft spd sig
• Out shaft spd gnd
• Over- drive off ind
• Overdrive switch
• Pnk
• Pnp sw sense
• Powertrain control module (in eng compt, on right side of firewall)
• S107
• S126
• Sensor gnd
• Stop lamp switch (top of brake pedal bracket)
• T13
• T14
• T18
• T25
• T41
• T54
• T60
• Tcc sol ctrl
• Tp sens sig
• Trans od sw sense
• Trans rly ctrl
• Trans temp sens
• Transmission output shaft speed sensor (on left side of transmission)
• V40
• Var sol ctrl
• Vss signal
• Z12

8.0L, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2500 1998

List of elements for 8.0L, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2500 1998:

• (eng harn, 3.9l, 5.2l & 5.9l: rear of eng, top of bellhousing; 8.0l: rear of eng in branch to transmission) s125
• Controller anti- lock brake (2wd: on left front inner fender, 4wd: mounted on top of hydraulic control unit)
• Engine controls system
• Engine coolant temperature sensor (on thermostat housing)
• Engine starter motor relay
• Fuse 20a
• Fuse m 10a
• Generator
• Governor pressure signal
• Hot at all times
• Joint connector
• Overdrive solenoid control
• Park/ neutral position switch (on left side of transmission)
• Pnk
• Power distribution center
• Power distribution center
• Red
• S116 (eng harn, 3.9l, 5.2l & 5.9l: rear of eng, on firewall; 8.0l: rear of eng)
• S118 (eng harn, 3.9l, 5.2l, & 5.9l: rear of eng, center of firewall; 8.0l: rear of eng)
• S119 (eng harn, 3.9l, 5.2l, & 5.9l: rear of eng, center of firewall; 8.0l: rear of eng)
• S121 eng harn, near fuel inj 5 breakout)
• S127 (eng harn, top center of transmission)
• Sensor ground
• Throttle position sensor (on throttle body)
• Torque converter clutch solenoid control
• Trans ctrl rly output
• Transmission control relay
• Transmission solenoid assembly (transmission)
• Transmission temperature sensor signal
• Variable force solenoid control