TRANSMISSION – Ford Econoline E150 2004 – SYSTEM WIRING DIAGRAMS

TRANSMISSION

4.6L

4.6L, A/T Wiring Diagram (1 of 2) for Ford Econoline E150 2004

List of elements for 4.6L, A/T Wiring Diagram (1 of 2) for Ford Econoline E150 2004:

• (at right rear side of engine compt) g116
• (at right side of engine compt) g107
• (eng ctrl sens harn, near breakout to c1033)
• (in eng ctrl sens harn, near breakout to c237)
• (in main
• (in window reg rly sw harn, near breakout to steering column)
• (main wiring harn, near breakout to left side of dash)
• (not used) c237
• (window reg rly sw harn, rear breakout to c248)
• Bpp
• Brake pedal position switch (on bracket, above brake pedal)
• Central junction box (behind left side of dash)
• Cht
• Data (+)
• Data (-)
• Data link connector (behind left side of dash, below left side of dash)
• Digital transmission range sensor
• Epc
• Except stripped chassis
• Exterior lights system
• Fuel tank pressure transducer sensor
• Fuse 10a
• Fuse 15a
• Gen data
• Gnd
• Hot at all times
• Hot in run or start
• Instrument cluster system
• Kapwr
• Maf
• Multifunction switch, deavtiator switch
• Nca
• Od off
• Oss
• Others
• Overdrive cancel switch
• Overhead console
• Powertrain control module (pcm) (in eng compt, on left side of firewall)
• Pwr in
• Red
• S134 (eng ctrl sens harn, near breakout to rear of eng compt)
• S135 (eng ctrl sens harn, near breakout to left rear of eng compt)
• S138
• S140
• S169
• S172
• S216
• S220 s224 (window reg rly sw harn, rear breakout to c237)
• S228 s182
• S269 s184
• Sig rtn
• Speed control servo
• Ssa
• Ssb
• Stripped chassis
• Tcc
• Tcil
• Tcs
• Tft
• Tps
• Tr1
• Tr2
• Tr3
• Tr4
• Vehicle security module
• Vref
• Vss
• Wiring harn, near breakout to left side of dash)

4.6L, A/T Wiring Diagram (2 of 2) for Ford Econoline E150 2004

List of elements for 4.6L, A/T Wiring Diagram (2 of 2) for Ford Econoline E150 2004:

• (at right rear side of engine compt) g116
• (at right side of engine compt) g107
• (eng ctrl harn, near breakout to left rear of eng compt)
• (in battery junction box)
• (in eng ctrl sens
• (in eng ctrl sens & fuel charging wiring harn, at left center of eng)
• (in headlamp lead wiring harn, in breakout to c1046)
• (near breakout at rear
• (top center of engine compt)
• 4r70e/4r75e transmission
• Battery junction box
• Battery junction box (left side of engine compt)
• Central junction box (behind left side of dash)
• Cylinder head temperature sensor (on top front of left cylinder head)
• Electronic pressure control solenoid
• Engine controls system
• Except stripped chassis
• Fuse 10a
• Fuse 30a
• Harn, near breakout to center of eng compt)
• Harn, near breakout to left rear of eng compt)
• Hot at all times
• Hot in run or start
• Ignition coil, radio noise capacitor
• Mass airflow (maf) sensor (at center of engine compt)
• Of eng)
• Output shaft speed sensor (left side of transmission)
• Pcm power diode
• Pcm power relay
• Red
• S100
• S102 (near breakout at rear
• S1033
• S1065
• S127
• S136
• S140
• S142
• S157
• S158
• Shift solenoids
• Ssa
• Ssb
• Stripped chassis
• Throttle position sensor (tps) (on top of engine, near air intake)
• Torque converter clutch solenoid
• Transmission fluid temperature sensor

5.4L

5.4L, A/T Wiring Diagram, with 4R100 Transmission (1 of 2) for Ford Econoline E150 2004

List of elements for 5.4L, A/T Wiring Diagram, with 4R100 Transmission (1 of 2) for Ford Econoline E150 2004:

• (1)
• (2)
• (at right rear side of engine compt) g116
• (at right side of engine compt) g107
• (eng ctrl sens harn, near breakout to c1033)
• (in eng ctrl sens
• (in main wiring harn, near breakout to left side of dash)
• (in window reg rly sw harn, near breakout to steering column)
• (not used) c237
• (window reg rly sw harn, rear breakout to c237)
• (window reg rly sw harn, rear breakout to c248)
• 6.8l
• Bpp
• Brake pedal position switch (on bracket, above brake pedal)
• Ccs
• Central junction box (behind left side of dash)
• Cht
• Data (+)
• Data (-)
• Data link connector (behind left side of dash, below left side of dash)
• Digital transmission range sensor
• Epc
• Except stripped chassis
• Exterior lights system
• Fuel tank pressure transducer sensor
• Fuse 10a
• Fuse 15a
• Gen data
• Gnd
• Harn, near breakout to c237)
• Hot at all times
• Hot in run or start
• Instrument cluster system
• Kapwr
• Maf
• Multifunction switch, deavtiator switch
• Nca
• Od off
• Oss
• Others
• Overdrive cancel switch
• Overhead console
• Powertrain control module (pcm) (in eng compt, on left side of firewall)
• Pwr in
• Red
• S134 (eng ctrl sens harn, near breakout to rear of eng compt)
• S135 (eng ctrl sens harn, near breakout to left rear of eng compt)
• S138
• S140
• S169
• S172
• S216
• S224 s220 (main wiring harn, near breakout to left side of dash)
• S228 s182
• S231 s283 (main wiring harn, in breakout to left side of dash)
• S269 s184
• Sig rtn
• Speed control servo
• Ssa
• Ssb
• Stripped chassis
• Tcc
• Tcil
• Tcs
• Tft
• Tps
• Tr1
• Tr2
• Tr3
• Tr4
• Tss
• Vehicle security module
• Vref
• Vss

5.4L, A/T Wiring Diagram, with 4R100 Transmission (2 of 2) for Ford Econoline E150 2004

List of elements for 5.4L, A/T Wiring Diagram, with 4R100 Transmission (2 of 2) for Ford Econoline E150 2004:

• (at right rear side of engine compt) g116
• (at right side of engine compt) g107
• (eng ctrl harn, near breakout to left rear of eng compt) s136
• (in battery junction box)
• (in eng ctrl
• (in eng ctrl sens & fuel charging warning harn, at left center of eng)
• (in eng ctrl sens harn, near breakout to left rear of eng compt)
• (in headlamp lead wiring harn, in breakout to c1046)
• (in trans ctrl selector neutral sw, near breakout at top of transmission)
• (in trans ctrl selector neutral sw: w/o ngv: near breakout at rear of eng, w/ ngv: near breakout at right side of transmission)
• (top center of engine compt)
• 4r100 transmission
• Battery junction box
• Battery junction box (left side of engine compt)
• Central junction box (behind left side of dash)
• Coast clutch solenoid
• Cylinder head temperature sensor (on top front of left cylinder head)
• Electronic pressure control solenoid
• Engine controls system
• Except stripped chassis
• Fuse 10a
• Fuse 30a
• Gasoline
• Hot at all times
• Hot in run or start
• Ignition coil, radio noise capacitor
• Mass airflow (maf) sensor (at center of engine compt)
• Natural gas vehicle
• Output shaft speed sensor (left side of transmission)
• Pcm power diode
• Pcm power relay
• Red
• S100
• S102
• S1033
• S127 s1065
• S140
• S142
• S157
• S158
• Sens harn, near breakout to center of eng compt)
• Shift solenoid a
• Shift solenoid b
• Stripped chassis
• Throttle position sensor (tps) (on top of engine, near air intake)
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Turbine shaft sensor (at left side of transmission)

5.4L, A/T Wiring Diagram, with 4R70E/4R75E (1 of 2) for Ford Econoline E150 2004

List of elements for 5.4L, A/T Wiring Diagram, with 4R70E/4R75E (1 of 2) for Ford Econoline E150 2004:

• (at right rear side of engine compt) g116
• (at right side of engine compt) g107
• (eng ctrl sens harn, near breakout to c1033)
• (in eng ctrl sens harn, near breakout to c237)
• (in main
• (in window reg rly sw harn, near breakout to steering column)
• (main wiring harn, near breakout to left side of dash)
• (not used) c237
• (window reg rly sw harn, rear breakout to c248)
• Bpp
• Brake pedal position switch (on bracket, above brake pedal)
• Central junction box (behind left side of dash)
• Cht
• Data (+)
• Data (-)
• Data link connector (behind left side of dash, below left side of dash)
• Digital transmission range sensor
• Epc
• Except stripped chassis
• Exterior lights system
• Fuel tank pressure transducer sensor
• Fuse 10a
• Fuse 15a
• Gen data
• Gnd
• Hot at all times
• Hot in run or start
• Instrument cluster system
• Kapwr
• Maf
• Multifunction switch, deavtiator switch
• Nca
• Od off
• Oss
• Others
• Overdrive cancel switch
• Overhead console
• Powertrain control module (pcm) (in eng compt, on left side of firewall)
• Pwr in
• Red
• S134 (eng ctrl sens harn, near breakout to rear of eng compt)
• S135 (eng ctrl sens harn, near breakout to left rear of eng compt)
• S138
• S140
• S169
• S172
• S216
• S220 s224 (window reg rly sw harn, rear breakout to c237)
• S228 s182
• S269 s184
• Sig rtn
• Speed control servo
• Ssa
• Ssb
• Stripped chassis
• Tcc
• Tcil
• Tcs
• Tft
• Tps
• Tr1
• Tr2
• Tr3
• Tr4
• Vehicle security module
• Vref
• Vss
• Wiring harn, near breakout to left side of dash)

5.4L, A/T Wiring Diagram, with 4R70E/4R75E (2 of 2) for Ford Econoline E150 2004

List of elements for 5.4L, A/T Wiring Diagram, with 4R70E/4R75E (2 of 2) for Ford Econoline E150 2004:

• (at right rear side of engine compt) g116
• (at right side of engine compt) g107
• (eng ctrl harn, near breakout to left rear of eng compt)
• (in battery junction box)
• (in eng ctrl sens
• (in eng ctrl sens & fuel charging wiring harn, at left center of eng)
• (in headlamp lead wiring harn, in breakout to c1046)
• (near breakout at rear
• (top center of engine compt)
• 4r70e/4r75e transmission
• Battery junction box
• Battery junction box (left side of engine compt)
• Central junction box (behind left side of dash)
• Cylinder head temperature sensor (on top front of left cylinder head)
• Electronic pressure control solenoid
• Engine controls system
• Except stripped chassis
• Fuse 10a
• Fuse 30a
• Harn, near breakout to center of eng compt)
• Harn, near breakout to left rear of eng compt)
• Hot at all times
• Hot in run or start
• Ignition coil, radio noise capacitor
• Mass airflow (maf) sensor (at center of engine compt)
• Of eng)
• Output shaft speed sensor (left side of transmission)
• Pcm power diode
• Pcm power relay
• Red
• S100
• S102 (near breakout at rear
• S1033
• S1065
• S127
• S136
• S140
• S142
• S157
• S158
• Shift solenoids
• Ssa
• Ssb
• Stripped chassis
• Throttle position sensor (tps) (on top of engine, near air intake)
• Torque converter clutch solenoid
• Transmission fluid temperature sensor