TRANSMISSION – Ford Pickup F150 1996 – SYSTEM WIRING DIAGRAMS

TRANSMISSION

4.9L

4.9L, Transmission Wiring Diagram for Ford Pickup F150 1996

List of elements for 4.9L, Transmission Wiring Diagram for Ford Pickup F150 1996:

• (behind bottom of right cowl panel) g203
• (dash engine feed harness, near break out to egr control solenoid) s161
• (dash engine gauge feed harness, near break out to throttle position sensor (tps))
• (engine control sensor harness, near break out to brake warning resistor/diode assembly)
• (engine control sensor harness, near break out to left headlamp) s121
• (fuel charge harness, near break out to intake air temperature (iat) sensor
• (left front of engine compartment, top of upper radiator support) g108
• (right front of engine, compartment, on front of fender apron) g101
• (transmission harness, near break out to e40d transmission)
• 4x4
• Backup lamp switch to rear lamp feed harness, in break out to transmission range (tr) sensor)
• Boo
• Brake on/off (boo) switch (on brake/ clutch pedal support)
• C250
• C251
• C252
• Ccs
• Coast clutch solenoid
• Data (+)
• Data (-)
• Data feps
• Data link connector (dlc) (partial) (behind lower right side of i/p, before glove compartment)
• E40d transmission (below center of vehicle)
• Ect
• Electronic pressure control solenoid
• Engine compartment fuse box
• Engine coolant temperature (ect) sensor (center front of engine, on thermostat housing)
• Epc
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• Fuse panel
• G101 (right front of engine compartment, on front of fender apron)
• G104 (rear of left fender apron)
• Gnd
• Hot at all times
• Hot in start or run
• Iat
• Instrument cluster
• Intake air temperature (iat) sensor (right front of engine, near intake runner 1)
• Kapwr
• Maf
• Malfunction indicator lamp (mil)
• Mass air flow sensor (right front of engine compartment)
• Mil
• N d
• Nca
• Pcm power diode
• Pcm power relay
• Power
• Powertrain control module (left side of safety wall)
• Psom module
• Red
• S102
• S104
• S106
• S135
• S136
• S137
• S138
• S146
• S148
• S169
• S215
• S216
• S236
• Shift solenoid
• Sig rtn
• Ss1
• Ss2
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position sensor (tps) (top left rear of engine, on throttle body)
• Torque converter clutch solenoid
• Transfer case circuit
• Transmission control switch
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of transmission)
• Vref
• Vss
• Vss gnd
• Vss output

Transfer Case Wiring Diagram for Ford Pickup F150 1996

List of elements for Transfer Case Wiring Diagram for Ford Pickup F150 1996:

• (behiind bottom of left cowl panel) g200
• (behind bottom of right cowl panel) g203
• (left front of engine compartment, on upper radiator support) g108
• (main harness, near break out to clutch pedal position switch or jumper)
• (main harness, near break out to in-line connector, behind lower center of i/p, near trailer electronic ctrl unit) s244
• 4x2
• 4x4
• 4x4 hi/low indicator switch (on front of transfer case)
• 4x4 indicator
• Anti-lock brakes system (rear anti-lock brake module)
• Bronco
• C.b. 20a
• C221
• C222
• C223
• C250
• Electronic shift control module (behind right cowl panel)
• Electronic shift control switch
• F-series
• F-series only
• Fuse 10a
• Fuse 4a
• Fuse panel
• G200 (behind bottom of left cowl panel)
• Hot at all times
• Hot in run
• Hot in start or run
• Hot with main light switch in park or head position
• Instrument cluster
• Isolation diode
• Low range
• Low range indicator
• Magnetic clutch coil
• Motor position sensor
• Nca
• S174 (engine control sensor harness, near break out to brake warning resistor/diode assembly)
• S202
• S203
• S210
• S215
• S218
• S237
• S242
• S245
• S258
• Shift motor
• Speed sensor
• Transfer case assembly (on rear of transmission)
• Transmission range (tr) sensor (left side of transmission)
• W/4r70w
• W/e40d

5.0L

5.0L, 4R7OW Transmission Wiring Diagram for Ford Pickup F150 1996

List of elements for 5.0L, 4R7OW Transmission Wiring Diagram for Ford Pickup F150 1996:

• (backup lamp switch to rear lamp feed harness, in break out to 4r70w transmission)
• (backup lamp switch to rear lamp feed harness, in break out to transmission range (tr) sensor) s146
• (bronco) s101 (f-series) s106
• (engine control sensor harness, near break out to brake warning resistor/diode assembly) (bronco) (engine control sensor harness, near break out to harness in-line connector, near starter relay) (f series)
• (engine control sensor harness, near break out to left headlamp) (bronco) s121
• (fuel charge harness, near break out to canister purge solenoid) (f-series) (no location available) (bronco)
• (left front of engine compartment, on upper radiator support) g108
• (main harness, near break out to speed control amplifier)
• 4r70w transmission (below center of vehicle)
• 4x4
• Boo
• Brake on/off (boo) switch (on brake/ clutch pedal support)
• Bronco
• C250
• C251
• C252
• Data
• Data (+)
• Data (-)
• Data link connector (dlc) (partial) (behind lower right side of i/p, below glove compartment)
• Ect
• Engine compartment fuse box
• Engine coolant temperature (ect) sensor (center front of engine, on heater tube) (bronco) (center front of engine, on thermostat housing) (f-series)
• Epc
• F-series
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• Fuse panel
• G101 (right front of engine compartment, front of fender apron)
• G104 (rear of left fender apron)
• Gnd
• Hot at all times
• Hot in start or run
• Iat
• Instrument cluster
• Intake air temperature (iat) sensor (left front of engine compartment) (bronco) (top center front of engine, near intake runner 6) (f-series)
• Kapwr
• Maf
• Malfunction indicator lamp (mil)
• Mass air flow (maf) sensor (left front of engine compartment) (bronco) (right front of engine compartment) (f-series)
• Mil
• N d
• Nca
• Oss
• Output shaft speed (oss) sensor (left rear of transmission)
• Pcm power diode
• Pcm power relay
• Power
• Powertrain control module (left side of safety wall)
• Psom module
• Red
• S102
• S104
• S124
• S127
• S135
• S136 (engine control sensor harness, near break out to brake warning resistor/ diode assembly)
• S137 (engine control sensor harness, near break out to brake warning resistor/diode assembly)
• S148
• S161 (fuel charge harness, near break out to fuel injector 4)
• S215
• S236
• S240 (f-series) (main harness, near break out to clutch pedal position switch or jumper)
• S246
• Series)
• Shift sol 1
• Shift sol 2
• Sig rtn
• Signal rtn
• Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
• Ss1
• Ss2
• Tcc
• Tcc sol
• Tcil
• Tcs
• Tft
• Tft sensor
• Throttle position (tp) sensor (top right front of engine, on throttle body)
• Transfer case circuit
• Transmission control switch
• Transmission range (tr) sensor (left side of transmission)
• Vehicle pwr
• Vref
• Vrs rtn
• Vss
• Vss input
• Vss output

5.0L, E4OD Transmission Wiring Diagram for Ford Pickup F150 1996

List of elements for 5.0L, E4OD Transmission Wiring Diagram for Ford Pickup F150 1996:

• (back lamp switch harness, in break out to transmission) (bronco) (transmission harness, near break out to e40d transmission) (f-series)
• (backup lamp switch to rear lamp feed harness, in break out to transmission range (tr) sensor)
• (behind bottom of right cowl panel) g203
• (bronco) s101 (f-series) s106
• (engine control sensor harness, near break out to brake warning resistor/diode assembly)
• (engine control sensor harness, near break out to left headlamp) (bronco) s121
• (fuel charge harness, near break out to canister purge solenoid) (f-series) (no location available) (bronco)
• (left front of engine compartment, on upper radiator support) g108
• (main harness, near break out to speed control amplifier)
• (right front of engine, compartment, front of fender apron) g101
• 4x4
• Boo
• Brake on/off (boo) switch (on brake/ clutch pedal support)
• Bronco
• C250
• C251
• C252
• Ccs
• Coast clutch solenoid
• Data (+)
• Data (-)
• Data feps
• Data link connector (dlc) (partial) (behind lower right side of i/p, below glove compartment)
• E40d transmission (below center of vehicle)
• Ect
• Electronic pressure control solenoid
• Engine compartment fuse box
• Engine coolant temperature (ect) sensor (center front of engine, on heater tube) (bronco) (center front of engine, on thermostat housing) (f-series)
• Epc
• F-series
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• Fuse panel
• G101 (right front of engine compartment, front of fender apron)
• G104 (rear of left fender apron)
• Gnd
• Hot at all times
• Hot in start or run
• Iat
• Instrument cluster
• Intake air temperature (iat) sensor (left front of engine compartment) (bronco) (top center front of engine, near intake runner 6) (f-series)
• Kapwr
• Maf
• Malfunction indicator lamp (mil)
• Mass air flow (maf) sensor (left front of engine compartment) (bronco) (right front of engine compartment) (f-series)
• Mil
• N d
• Nca
• Pcm power diode
• Pcm power relay
• Power
• Powertrain control module (left side of safety wall)
• Psom module
• Red
• S101 (bronco) s106 (f-series)
• S102
• S104
• S135
• S136
• S137 (engine control sensor harness, near break out to brake warning resistor/ diode assembly)
• S146
• S148
• S161 (fuel charge harness, near break out to fuel injector 4)
• S169
• S215
• S216
• S236
• S240 (f-series) (main harness, near break out to clutch pedal position switch or jumper)
• S246
• Shift solenoid
• Sig rtn
• Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
• Ss1
• Ss2
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position (tp) sensor (top right front of engine, on throttle body)
• Torque converter clutch solenoid
• Transfer case circuit
• Transmission control switch
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of transmission)
• Vref
• Vss
• Vss gnd
• Vss input
• Vss output

Transfer Case Wiring Diagram for Ford Pickup F150 1996

List of elements for Transfer Case Wiring Diagram for Ford Pickup F150 1996:

• (behiind bottom of left cowl panel) g200
• (behind bottom of right cowl panel) g203
• (left front of engine compartment, on upper radiator support) g108
• (main harness, near break out to clutch pedal position switch or jumper)
• (main harness, near break out to in-line connector, behind lower center of i/p, near trailer electronic ctrl unit) s244
• 4x2
• 4x4
• 4x4 hi/low indicator switch (on front of transfer case)
• 4x4 indicator
• Anti-lock brakes system (rear anti-lock brake module)
• Bronco
• C.b. 20a
• C221
• C222
• C223
• C250
• Electronic shift control module (behind right cowl panel)
• Electronic shift control switch
• F-series
• F-series only
• Fuse 10a
• Fuse 4a
• Fuse panel
• G200 (behind bottom of left cowl panel)
• Hot at all times
• Hot in run
• Hot in start or run
• Hot with main light switch in park or head position
• Instrument cluster
• Isolation diode
• Low range
• Low range indicator
• Magnetic clutch coil
• Motor position sensor
• Nca
• S174 (engine control sensor harness, near break out to brake warning resistor/diode assembly)
• S202
• S203
• S210
• S215
• S218
• S237
• S242
• S245
• S258
• Shift motor
• Speed sensor
• Transfer case assembly (on rear of transmission)
• Transmission range (tr) sensor (left side of transmission)
• W/4r70w
• W/e40d

5.8L

5.8L, Transmission Wiring Diagram for Ford Pickup F150 1996

List of elements for 5.8L, Transmission Wiring Diagram for Ford Pickup F150 1996:

• (back lamp switch harness, in break out to transmission) (bronco) (transmission harness, near break out to e40d transmission) (f-series)
• (backup lamp switch to rear lamp feed harness, in break out to transmission range (tr) sensor)
• (behind bottom of right cowl panel) g203
• (bronco) s101 (f-series) s106
• (engine control sensor harness, near break out to brake warning resistor/diode assembly)
• (engine control sensor harness, near break out to left headlamp) (bronco) s121
• (fuel charge harness, near break out to canister purge solenoid) (f-series) (no location available) (bronco)
• (left front of engine compartment, on upper radiator support) g108
• (main harness, near break out to speed control amplifier)
• (right front of engine, compartment, front of fender apron) g101
• 4x4
• Boo
• Brake on/off (boo) switch (on brake/ clutch pedal support)
• Bronco
• C250
• C251
• C252
• Ccs
• Coast clutch solenoid
• Data (+)
• Data (-)
• Data feps
• Data link connector (dlc) (partial) (behind lower right side of i/p, below glove compartment)
• E40d transmission (below center of vehicle)
• Ect
• Electronic pressure control solenoid
• Engine compartment fuse box
• Engine coolant temperature (ect) sensor (center front of engine, on heater tube) (bronco) (center front of engine, on thermostat housing) (f-series)
• Epc
• F-series
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• Fuse panel
• G101 (right front of engine compartment, front of fender apron)
• G104 (rear of left fender apron)
• Gnd
• Hot at all times
• Hot in start or run
• Iat
• Instrument cluster
• Intake air temperature (iat) sensor (left front of engine compartment) (bronco) (top center front of engine, near intake runner 6) (f-series)
• Kapwr
• Maf
• Malfunction indicator lamp (mil)
• Mass air flow (maf) sensor (left front of engine compartment) (bronco) (right front of engine compartment) (f-series)
• Mil
• N d
• Nca
• Pcm power diode
• Pcm power relay
• Power
• Powertrain control module (left side of safety wall)
• Psom module
• Red
• S101 (bronco) s106 (f-series)
• S102
• S104
• S135
• S136
• S137 (engine control sensor harness, near break out to brake warning resistor/ diode assembly)
• S146
• S148
• S161 (fuel charge harness, near break out to fuel injector 4)
• S169
• S215
• S216
• S236
• S240 (f-series) (main harness, near break out to clutch pedal position switch or jumper)
• S246
• Shift solenoid
• Sig rtn
• Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
• Ss1
• Ss2
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position (tp) sensor (top right front of engine, on throttle body)
• Torque converter clutch solenoid
• Transfer case circuit
• Transmission control switch
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of transmission)
• Vref
• Vss
• Vss gnd
• Vss input
• Vss output

Transfer Case Wiring Diagram for Ford Pickup F150 1996

List of elements for Transfer Case Wiring Diagram for Ford Pickup F150 1996:

• (behiind bottom of left cowl panel) g200
• (behind bottom of right cowl panel) g203
• (left front of engine compartment, on upper radiator support) g108
• (main harness, near break out to clutch pedal position switch or jumper)
• (main harness, near break out to in-line connector, behind lower center of i/p, near trailer electronic ctrl unit) s244
• 4x2
• 4x4
• 4x4 hi/low indicator switch (on front of transfer case)
• 4x4 indicator
• Anti-lock brakes system (rear anti-lock brake module)
• Bronco
• C.b. 20a
• C221
• C222
• C223
• C250
• Electronic shift control module (behind right cowl panel)
• Electronic shift control switch
• F-series
• F-series only
• Fuse 10a
• Fuse 4a
• Fuse panel
• G200 (behind bottom of left cowl panel)
• Hot at all times
• Hot in run
• Hot in start or run
• Hot with main light switch in park or head position
• Instrument cluster
• Isolation diode
• Low range
• Low range indicator
• Magnetic clutch coil
• Motor position sensor
• Nca
• S174 (engine control sensor harness, near break out to brake warning resistor/diode assembly)
• S202
• S203
• S210
• S215
• S218
• S237
• S242
• S245
• S258
• Shift motor
• Speed sensor
• Transfer case assembly (on rear of transmission)
• Transmission range (tr) sensor (left side of transmission)
• W/4r70w
• W/e40d