TRANSMISSION – Ford Ranger Splash 1997 – SYSTEM WIRING DIAGRAMS

TRANSMISSION

2.3L

2.3L, Transmission Wiring Diagram, 4R44E for Ford Ranger Splash 1997

List of elements for 2.3L, Transmission Wiring Diagram, 4R44E for Ford Ranger Splash 1997:

• (dash panel to headlamp junction harness, near breakout to left headlamp)
• (engine control sensor extension harness, near breakout to harness in-line connector, left rear of engine)
• (engine control sensor harness, near breakout to ground g123)
• (engine control sensor harness, near breakout to intake air temp (iat) sensor)
• (engine control sensor harness, near breakout to throttle position (tp) sensor)
• (left side of upper radiator support) g108
• (power for heated oxygen sensors)
• (right side of firewall) g123
• (top center of left fender apron) g104
• 4r44e automatic transmission (left side of transmission)
• Boo
• Brake on/off (boo) switch (on brake pedal support)
• C111
• C214
• C216
• Case gnd
• Ccs
• Coast clutch solenoid (css)
• Cse gnd
• Digital transmission range sensor (left side of trans)
• Dlc
• Dlc (+)
• Dlc (-)
• Drl module, backup lamps, dtr sensor
• Ect
• Electronic pressure control (epc) solenoid
• Engine compartment fuse/relay box
• Engine controls
• Engine controls (ignition coil, radio noise capacitor)
• Engine coolant temperature (ect) sensor (top right front of eng, in water outlet tube)
• Epc
• Fuse 13 15a
• Fuse 19 25a
• Fuse 26 10a
• G108 (left side of upper radiator support)
• Ho2s fuse 3 15a
• Hot at all times
• Hot in run
• Hot in start or run
• I/p fuse panel
• Instrument cluster
• Kapwr
• Malfunction indicator lamp (mil)
• Memory power fuse 5 15a
• Mil
• O/d off
• Pcm power diode
• Pcm power fuse 2 30a
• Pcm power relay
• Power
• Powertrain control module (pcm) (right rear of engine compartment, through firewall)
• Pwr gnd
• R p
• Red
• S100
• S1002
• S102
• S103
• S104
• S106
• S110
• S111
• S121
• S147
• S228 (main harn, near breakout to instrument cluster)
• Shift solenoid (ss1)
• Shift solenoid (ss2)
• Shift solenoid (ss3)
• Sig rtn
• Ss1
• Ss2
• Ss3
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position (tp) sensor (top right side of engine, on throttle body)
• Torque converter clutch (tcc) solenoid
• Tr1
• Tr2
• Tr4
• Transmission control indicator lamp (tcil)
• Transmission control switch (tcs)
• Transmission fluid temperature (tft) sensor
• Tss
• Turbine shaft speed (tss) sensor
• Vehicle speed sensor (vss) (left rear of transmission) (4x2 models) (left rear of transfer case) (4x4 models)
• Vref
• Vss

Transfer Case Wiring Diagram for Ford Ranger Splash 1997

List of elements for Transfer Case Wiring Diagram for Ford Ranger Splash 1997:

• (behind dash, right side of steering column) relay box 1
• (main harness, in breakout to generic electronic module (gem) connectors)
• (main harness, near breakout to dash fuse panel)
• (top center of left fender apron) g104
• 1.1k ohms
• 3.9k ohms
• 4 wheel drive fuse 4 20a
• 4wd hi ind
• 4wd ind ctrl
• 4wd lo ind
• 4wd mode sw
• 4wd mode switch
• 4wd motor
• 4wd output
• Battery saver relay
• Boo sw input
• Brake on/off (boo) switch (on brake pedal support)
• C214
• C221
• C223
• C224
• Ccw relay
• Ccw rly ctrl
• Clutch
• Cw relay
• Cw rly ctrl
• Digital transmission range (dtr) sensor (left side of transmission)
• Elc rly ctrl
• Electric clutch relay
• Electric shift control module (behind center of dash)
• Engine compartment fuse/relay box
• Fuse 13 15a
• Fuse 27 15a
• Fuse 3 in i/p fuse panel (feed to park lamps relay)
• G104 (top center of left fender apron)
• Generic electronic module (gem) (behind center of dash)
• Hot at all times
• I/p fuse panel
• Illumination
• Instrument cluster
• Interior lights
• Interior lights system (instrument illum- ination circuit)
• Nca
• Neutral sw in
• Of firewall) g123
• Ohms
• Park lamps fuse 8 20a
• Pnk
• Relay box 1 (behind dash, right side of steering column)
• Rly ctrl
• S107
• S111 (engine control sensor harness, near breakout to fuel injector 6)
• S209
• S215
• S216
• S218
• S221
• S224
• S228 (main harness, near breakout to instrument cluster connectors)
• S237
• Sig return
• Sw a input
• Sw b input
• Sw c input
• Sw d input
• Touch drive
• Transfer case assembly (below vehicle, behind transmission)
• Vehicle speed sensor (vss) (4x4 models - left rear of transfer case) (4x2 models - left rear of trans)
• Vss
• Wiper/washer (multi-function switch)

3.0L

3.0L, Transmission Wiring Diagram, 4R44E for Ford Ranger Splash 1997

List of elements for 3.0L, Transmission Wiring Diagram, 4R44E for Ford Ranger Splash 1997:

• (dash panel to headlamp junction harness, near breakout to left headlamp)
• (engine control sensor extension harness, near breakout to harness in-line connector, left rear of engine)
• (engine control sensor harn, near breakout to in-line conn, at left rear of engine)
• (engine control sensor harness, near breakout to diff press feedback sensor)
• (engine control sensor harness, near breakout to evr solenoid)
• (engine control sensor harness, near breakout to in-line connector, at left rear of engine)
• (engine control sensor harness, near breakout to octane adjust shorting bar)
• (left side of upper radiator support) g108
• (power for heated oxygen sensors)
• (right side of firewall) g123
• (top center of left fender apron) g104
• 4r44e automatic transmission (left side of transmission)
• Boo
• Brake on/off (boo) switch (on brake pedal support)
• C111
• C214
• C216
• Case gnd
• Ccs
• Coast clutch solenoid (css)
• Cse gnd
• Digital transmission range sensor (left side of trans)
• Dlc
• Dlc (+)
• Dlc (-)
• Drl module, backup lamps, dtr sensor
• Ect
• Electronic pressure control (epc) solenoid
• Engine compartment fuse/relay box
• Engine controls
• Engine controls (ignition coil, radio noise capacitor)
• Engine coolant temperature (ect) sensor (top front of engine)
• Epc
• Fuse 13 15a
• Fuse 19 25a
• Fuse 26 10a
• G108 (left side of radiator support)
• Ho2s fuse 3 15a
• Hot at all times
• Hot in run
• Hot in start or run
• I/p fuse panel
• Instrument cluster
• Kapwr
• Malfunction indicator lamp (mil)
• Memory power fuse 5 15a
• Mil
• O/d off
• Pcm power diode
• Pcm power fuse 2 30a
• Pcm power relay
• Power
• Powertrain control module (pcm) (right rear of engine compartment, through firewall)
• Pwr gnd
• R p
• Red
• S100 (engine control sensor harness, near breakout to intake air temp sensor)
• S1002
• S102
• S103
• S104
• S106
• S110
• S111
• S112
• S113
• S121
• S147
• S228 (main harn, near breakout to instrument cluster)
• Shift solenoid (ss1)
• Shift solenoid (ss2)
• Shift solenoid (ss3)
• Sig rtn
• Ss1
• Ss2
• Ss3
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position (tp) sensor (top right side of engine, on throttle body)
• Torque converter clutch (tcc) solenoid
• Tr1
• Tr2
• Tr4
• Transmission control indicator lamp (tcil)
• Transmission control switch (tcs)
• Transmission fluid temperature (tft) sensor
• Tss
• Turbine shaft speed (tss) sensor
• Vehicle speed sensor (vss) (left rear of transmission) (4x2 models) (left rear of transfer case) (4x4 models)
• Vref
• Vss

Transfer Case Wiring Diagram for Ford Ranger Splash 1997

List of elements for Transfer Case Wiring Diagram for Ford Ranger Splash 1997:

• (behind dash, right side of steering column) relay box 1
• (main harness, in breakout to generic electronic module (gem) connectors)
• (main harness, near breakout to dash fuse panel)
• (top center of left fender apron) g104
• 1.1k ohms
• 3.9k ohms
• 4 wheel drive fuse 4 20a
• 4wd hi ind
• 4wd ind ctrl
• 4wd lo ind
• 4wd mode sw
• 4wd mode switch
• 4wd motor
• 4wd output
• Battery saver relay
• Boo sw input
• Brake on/off (boo) switch (on brake pedal support)
• C214
• C221
• C223
• C224
• Ccw relay
• Ccw rly ctrl
• Clutch
• Cw relay
• Cw rly ctrl
• Digital transmission range (dtr) sensor (left side of transmission)
• Elc rly ctrl
• Electric clutch relay
• Electric shift control module (behind center of dash)
• Engine compartment fuse/relay box
• Fuse 13 15a
• Fuse 27 15a
• Fuse 3 in i/p fuse panel (feed to park lamps relay)
• G104 (top center of left fender apron)
• Generic electronic module (gem) (behind center of dash)
• Hot at all times
• I/p fuse panel
• Illumination
• Instrument cluster
• Interior lights
• Interior lights system (instrument illum- ination circuit)
• Nca
• Neutral sw in
• Of firewall) g123
• Ohms
• Park lamps fuse 8 20a
• Pnk
• Relay box 1 (behind dash, right side of steering column)
• Rly ctrl
• S107
• S111 (engine control sensor harness, near breakout to fuel injector 6)
• S209
• S215
• S216
• S218
• S221
• S224
• S228 (main harness, near breakout to instrument cluster connectors)
• S237
• Sig return
• Sw a input
• Sw b input
• Sw c input
• Sw d input
• Touch drive
• Transfer case assembly (below vehicle, behind transmission)
• Vehicle speed sensor (vss) (4x4 models - left rear of transfer case) (4x2 models - left rear of trans)
• Vss
• Wiper/washer (multi-function switch)

4.0L

4.0L, Transmission Wiring Diagram, 5R55E for Ford Ranger Splash 1997

List of elements for 4.0L, Transmission Wiring Diagram, 5R55E for Ford Ranger Splash 1997:

• (dash panel to headlamp junction harness, near breakout to left headlamp)
• (engine control sensor extension harness, near breakout to harness in-line connector, left rear of engine)
• (engine control sensor harness, near breakout to diff press feedback sensor)
• (engine control sensor harness, near breakout to fuel inj 6)
• (engine control sensor harness, near breakout to fuel injector 5)
• (engine control sensor harness, near breakout to fuel injector 6)
• (engine control sensor harness, near breakout to mass air flow sensor)
• (engine control sensor harness, near breakout to powertrain control module)
• (near dtr sensor) output shaft speed sensor
• (near dtr sensor) overdrive drum speed sensor
• (power for heated oxygen sensors)
• (top center of left fender apron) g104
• 5r55e automatic transmission (left side of transmission)
• Boo
• Brake on/off (boo) switch (on brake pedal support)
• C111
• C214
• C216
• Case gnd
• Ccs
• Coast clutch solenoid (css)
• Cse gnd
• Digital transmission range sensor (left side of trans)
• Dlc
• Dlc (+)
• Dlc (-)
• Drl module, backup lamps, dtr sensor
• Ect
• Electronic pressure control (epc) solenoid
• Engine compartment fuse/relay box
• Engine compartment fuse/relay box (left rear of eng compt)
• Engine controls
• Engine controls (ignition coil, radio noise capacitor)
• Engine coolant temperature (ect) sensor (top front of engine)
• Epc
• Fuse 13 15a
• Fuse 19 25a
• Fuse 26 10a
• G108 (left side of radiator support)
• G108 (left side of upper radiator support)
• G123 (right side of firewall)
• Ho2s fuse 3 15a
• Hot at all times
• Hot in run
• Hot in start or run
• I/p fuse panel
• Instrument cluster
• Kapwr
• Malfunction indicator lamp (mil)
• Memory power fuse 5 15a
• Mil
• O/d off
• Ods
• Oss
• Pcm power diode
• Pcm power fuse 2 30a
• Pcm power relay
• Power
• Powertrain control module (pcm) (right rear of engine compartment, through firewall)
• Pwr gnd
• R p
• Red
• S100 (engine control sensor harness, near breakout to intake air temp sensor)
• S1002
• S102
• S103
• S104
• S106
• S110
• S111
• S112
• S113
• S121
• S147
• S228 (main harn, near breakout to instrument cluster)
• Shift solenoid (ss1)
• Shift solenoid (ss2)
• Shift solenoid (ss3)
• Sig rtn
• Ss1
• Ss2
• Ss3
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position (tp) sensor (top right side of engine, on throttle body)
• Torque converter clutch (tcc) solenoid
• Tr1
• Tr2
• Tr4
• Transmission control indicator lamp (tcil)
• Transmission control switch (tcs)
• Transmission fluid temperature (tft) sensor
• Tss
• Turbine shaft speed (tss) sensor
• Vehicle speed sensor (vss) (left rear of transmission) (4x2 models) (left rear of transfer case) (4x4 models)
• Vref
• Vss

Transfer Case Wiring Diagram for Ford Ranger Splash 1997

List of elements for Transfer Case Wiring Diagram for Ford Ranger Splash 1997:

• (behind dash, right side of steering column) relay box 1
• (main harness, in breakout to generic electronic module (gem) connectors)
• (main harness, near breakout to dash fuse panel)
• (top center of left fender apron) g104
• 1.1k ohms
• 3.9k ohms
• 4 wheel drive fuse 4 20a
• 4wd hi ind
• 4wd ind ctrl
• 4wd lo ind
• 4wd mode sw
• 4wd mode switch
• 4wd motor
• 4wd output
• Battery saver relay
• Boo sw input
• Brake on/off (boo) switch (on brake pedal support)
• C214
• C221
• C223
• C224
• Ccw relay
• Ccw rly ctrl
• Clutch
• Cw relay
• Cw rly ctrl
• Digital transmission range (dtr) sensor (left side of transmission)
• Elc rly ctrl
• Electric clutch relay
• Electric shift control module (behind center of dash)
• Engine compartment fuse/relay box
• Fuse 13 15a
• Fuse 27 15a
• Fuse 3 in i/p fuse panel (feed to park lamps relay)
• G104 (top center of left fender apron)
• Generic electronic module (gem) (behind center of dash)
• Hot at all times
• I/p fuse panel
• Illumination
• Instrument cluster
• Interior lights
• Interior lights system (instrument illum- ination circuit)
• Nca
• Neutral sw in
• Of firewall) g123
• Ohms
• Park lamps fuse 8 20a
• Pnk
• Relay box 1 (behind dash, right side of steering column)
• Rly ctrl
• S107
• S111 (engine control sensor harness, near breakout to fuel injector 6)
• S209
• S215
• S216
• S218
• S221
• S224
• S228 (main harness, near breakout to instrument cluster connectors)
• S237
• Sig return
• Sw a input
• Sw b input
• Sw c input
• Sw d input
• Touch drive
• Transfer case assembly (below vehicle, behind transmission)
• Vehicle speed sensor (vss) (4x4 models - left rear of transfer case) (4x2 models - left rear of trans)
• Vss
• Wiper/washer (multi-function switch)